Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Con>Format
Con>Format, Briefly..........................................1
Configuring Con>Format.......................................1
Operating Con>Format.........................................4
In Conclusion................................................6
Sydex
P.O. Box 5700
Eugene, OR 97405
Voice: (503) 683-6033
FAX: (503) 683-1622
Data: (503) 683-1385
NOTICE
REGISTRATION INFORMATION
DISTRIBUTION NOTICE
So why waste your time staring at "Formatting Track 13, Side 1"
displays? Give Con>Format a try--pretty soon you'll be wondering
why you ever put up with DOS Format!
Configuring Con>Format
Page 1
You need only copy the file CONFMT.COM from the installation dis-
kette to a directory or drive where it may be accessed. To load
Con>Format into memory, simply type the following at the DOS
prompt:
CONFMT S
Page 2
else you tried to do! If you find that your "hot key" selection
was not a good one, you can run INSTALL again to re-install
Con>Format with a different "hot key" combination.
Page 3
* Finally, you may specify if Con>Format is to signal comple-
tion of the formatting process by a tone instead of, or in
addition to, a "pop-up" status window. If a tone signal
is selected, a high, medium or low tone is sounded to in-
dicate that the diskette you just formatted had:
Operating Con>Format
Page 4
If flawed areas of the diskette were encountered, the total size
of the flawed areas is displayed. In some cases it may not be
possible to format a diskette because the drive door was left
open, the diskette was write-disabled, or a flaw was detected in
a critical area of the diskette. Con>Format will diagnose each
of these conditions and display an appropriate message.
When Con>Format displays its window, you may move the window
around the screen with the cursor keypad. Each key moves the
window as follows:
Page 5
Removing Con>Format From Memory
You can remove Con>Format from your computer's memory with the
command:
CONFMT R
In Conclusion
Page 6
The Sydex Product Line
Sydex
P.O. Box 5700
Eugene, OR 97405
Voice: (503) 683-6033
FAX: (503) 683-1622
Data: (503) 683-1385
Page 7