Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Connection – Disconnection
1. Connection
Start the power pack
Line up 2 trailers
Put both trailers on the same level using jacking system
Jacking system
controls / levers
Attach the trailers together. Any hydraulic hose should be disconnected during
this operation.
Put the selector valve of the trailer connected to power pack in jacking
position.
Open the valves on the lines of fastening jacks. Open the pressure control valve
of fastening jacks.
Valves of
fastening jack
Fastening jack
(in straight
position)
Fastening jack
control valve
Fasten 2 multi wheels with the jacks, put jacks in the straight position and
tighten the multi wheels.
Adjust the level of multi wheels.
Stop the power pack
Put and tighten bolts.
Fastening jack
Release all the pressure in both multi wheels, using jacking and steering
controls. To do it you need to put the trailer in the lower position using
jacking controls. It will transfer all the oil from the system to the oil tank.
Disconnect hydraulic hoses. No tools necessary to connect and disconnect hoses.
All connections should be tighten by hands.
Multi wheel DRAIZE
Steering line
connections
Connect the steering line. Only straight connection is possible (pressure line
with pressure line and return line with return line) – 2 hoses on each side and
2 hoses in the middle of the trailer = 6hoses.
Put in place the hose between the hydraulic tanks – 1 hose in the middle of the
trailers
Steering line
connections
Hydraulic tanks
connection
2. Disconnection
Level up the trailer.
Release the pressure from the hydraulic system opening jacking controls.
Remove connection bolts
Remove all the pneumatic hoses = 2 units.
Multi wheel DRAIZE
Remove all hydraulic hoses. No tools necessary to connect and disconnect hoses.
All connections should be untighten by hands.
Remove hoses of jacking line – 2 hoses on each side = 4
Remove hoses of steering line – 2 hoses on each side + 2 in the middle = 6
Remove hose between the hydraulic tanks – 1 hose in the middle
Total: 11
Connect jacking lines of each trailer – 1 hose on each side = 4 hoses for 2
trailers.
Steering valves
12 13 Steering Lever
9 10 Jack/Steering selector
╦
12 13 Jacking Lever
Draw bar
O Connector
O O
Front view where you can found the necessary valves and lever to operate (jacking
and steering) bogies using power pack with inside hydraulic tank (440 liters
capacity) (upper Illustration)
= x Steering valves
19
13
13
Jacking Lever
Steering Lever
O O O O