Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
kN. The shaft rotates at 1200 rpm. The expected life L10h of the bearing is 20000 hr. The minimum
acceptable diameter of the shaft is 85 mm . Select a suitable ball bearing for this application
When the bearing is subjected to radial as well as axial load, the values of X and Y factors are
obtained from table by trial and error procedure. It is observed from table that the values of X are
Fa
constant and the values of Y varies only in case when > e
Fr
In this case , the values of Y varies from 1 to 2 . We will assume the average value 1.5 as the first
trial value for factor Y
P= XFr+YFa P= 0.56(8000)+1.5(3000)=8980 N
60nL10 h 60(1200)20000
L10 L10 1440 million rev
106 106
0.03475 0.2365
Fa
Therefore corresponding to e=0.2365 and > e 0.375 > 0.2365
Fr
e Y
0.22 2
0.2365 1.835
C= P(L10 )1/3 =9985(1440)1/3 112754 N 11493 kgf
Choose 6417
A transmission shaft rotating at 720 rpm and transmitting power from pulley P to spur gear G is
shown in figure. The belt tensions and the gear tooth forces are as follows
P1= 498 N , P2=166 N , Pt= 497 N and Pr= 181 N
The weight of the pulley is 100 N. The diameter of the shaft at bearings B1 and B2 is 10 mm and
20 mm respectively. The load factor is 2.5 and the expected life for 90 % of bearing is 8000 hr.
Select single row deep groove ball bearing at B1 and B2
X and Y factors
The capacities of bearing No 6002 are
Co= 255 kgf or 2501 N and
C=440kgf or 4316 N
Fa 1000
Fa 1000
0.4545 0.399
Fr 2200 C0 2501
Referring table,
4.08 mr
L10
'
ln(1 / P10 ) 6.33 ln(1 / P10 ) 6.33 ln(1 / 0.9)
6.33 0.1053 6.33
L50 25.82 mr
A single row deep groove ball bearing has a dynamic load capacity of 40500N and operates on
the following work cycle
(a) Radial load of 5000 N at 500 rpm for 25 % of the time
(b) Radial load of 10000 N at 700 rpm for 50% of the time and
(c) Radial load of 7000 N at 400 rpm for the remaining 25% of the time
Calculate the expected life of the bearing in hours
Fm=8860 N
1 5000 0.25 500 125
575
Given: Fr=8 kN, Fa=3 kN X=0.56 Y=1.5 n=1200 rpm d=75 mm C=88290 N
P= XFr+YFa P= 0.56(8000)+1.5(3000)=8980 N
L ln(1 / p)
1/ b
L10
'
ln(1 / P10 )
20000 ln(1 / p)
1/ 1.17
13198.6 ln(1 / 0.9)
P= 84.26 %