Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Otherwise please ask your dealer for the ARROWS Add-On Drift-Stopper to avoid drifting.
HOW TO
iRIG:
SETUP BASE PLATE
When used on a board with a threaded hole: When used on a board with a slider-box: Connect the base to the board by turning CONNECT THE iRIG TO THE BASE:
Make sure to remove the nut-slider. Do not remove the nut-slider but loosen it it clockwise. Make sure the base sits tight Open the lever as indicated by the arrow.
so that you get the base into the box. on the board.
Now pull the lever as indicated by the Get the iRIG and... ... put the pin into the hole of the base. Now push the lever back inside as indicated Finally secure the lever in place by pushing
arrow to fully open the base. by the arrow. downwards. Now you‘re ready to go!
STEP 1 / 9 STEP 2 / 9 STEP 3 / 9 STEP 4 / 9
HOW TO
iRIG:
PACKING UP
PACKING UP:
Start folding here...