Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This plan is for YOUR use only. Do not redistribute or sell this plan. Feel free to use
this plan to make as many tables as you want and sell the actual table for profit.
Thank you for purchasing this plan and Have Fun!
5 -
1” x 12” x 8’ pine boards or equivalent
1 -
2” x 12” x 8’ pine board or equivalent
1 -
24” x 24” x 1/2” Plywood
1 -
3/8” oak dowel 36” long
4 -
1/2” oak dowel 36” long
1 -
small box of 1 1/4” pokethole screws 100 count is enough
1 -
small box of spax 1 1/4” or other wood screw
8 -
1” wood pan head screws
8 -
small washers that have a Dia of 3/4” and interior hole the heads of
the pan head screws will not fit through.
1 - 48” piano hinge your choice color cut down to 10” sections and round
the rough corners.
1 - small bottle exterior wood glue.
Layout Drawing
The layout drawing (on the next page) is just to show that all parts can be
cut out of the material in the shopping list. It is not measured guide. When
using natural materials you may need to adjust for knots and defects in the
wood. Its always a good idea to get a little more then what you think your
going to need.
Eizzy Folding Table Page | 3
Lets make some sawdust!
Starting a project and finishing a project are by far my 2 favorite parts
of any build. A couple of things to note about the plans before you jump
in. You will notice the hole sizes are not on the detail measurement of
each part i did this to avoid cluttering up the drawings. The holes for
the chair assembly, hinge blocks and lift housing are all 1/2” in dia. The
holes for the table top side wing hinges are all 3/8” dia.
Also there is an additional add on in the last section video that is not
in the plans. It is optional but worth taking a look at so if you don’t
watch any other videos be sure to check the last one out.
THE LIFT
HOUSING
CROSS BRACES
ARE IDENTI-
CAL EXCEPT
FOR THE HALF
LAP JOINT CUT
IN THE TOP
AND BOTTOM
CROSS BRACE.
THE THRU
HOLES ARE