Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Perform following procedure for each wheel end on trailer with end play at hub greater than 0.003 In. (0.08
mm) or wheel movement greater than 0.04 In. (1 mm).
7. Tighten spindle end nut to 810-850 Ft. Lbs. (1100-1150 N.m) while rotating wheel and hub in a
counterclockwise direction. Do not back off nut after tightening. Mark nut location relative to spindle.
Fig 4.
Fig 4: Tightening Spindle End Nut
8. Check for wheel-end movement to ensure wheel end rotates freely as described in inspection
procedure. Verify end play is less than 0.003 In. (0.08 mm) by following Steps 3, 4 and 5 of
Detailed Hub Inspection procedure.
1. If end play is greater than 0.003 In. (0.08 mm): Replace hub.
9. Use a hammer and staking tool (Figure) to stake washer to spindle nut in three positions. Fig 5 and
Fig 6.
Fig 5: Staking Stake Washer To Spindle Nut
Fig 6: Locating Stake Washer Edge In Cutting Position
10. Clean hub end surface and hubcap flange prior to reassembly of hubcap.
11. Install hubcap with a new gasket (part number 2208-B-1172). Install new hubcap capscrews. Tighten
hubcap capscrews in a crisscross pattern to 15-30 Ft. Lbs. (20-40 N.m).