Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
net Página 1 de 10
GBAtemp.net > Other Systems Discussions > Game Boy Advance Discussions > GBA - Hardware, Devices and
Utilities
7 Pages 1 2 3 > »
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS), If your saves don't
Options
work, your battery might be dead.
Feb 1 2009, 12:08 AM Post #1
haircut
I purchased my EZFlash V 3-in-1 expansion just over a year ago. All of a sudden, my GBA games stopped
saving. They played fine, but refused to save. I searched all over and finally concluded that my battery
Newbie
must be dead. The battery is necessary to hold a game's SRAM save.
Group: Newcomers When your battery dies, you can buy a new 3-in-1, or if you're not scared of electronics, you can change
Posts: 3
it.
Joined: 29-January 09
Member No.: 155,718
If your games aren't saving and you've exhausted your options (using GBAExploader, flashing
the game to NOR, etc), you probably have a dead battery. Changing it will fix your woes.
Some people have mentioned soldering a new battery onto the PCB, but that's not necessary. You can
change your battery with just a few household items and NO SOLDERING.
Please note: This guide assumes you've opened up some electronic devices in the past and understand
the risks of doing so. If you slip up or push something too hard or rip a component off, your 3-in-1 will be
dead. I am not responsible for any damage you cause to your own belongings. I'm simply
showing you what I did to change my battery. If you want to try it, I'm not responsible for the
outcome.
1. New Battery - CR1220, available from Radio Shack for just under $6
2. Electrical Tape
3. Scissors
4. Razor Blade, preferably with a handle to grip easily
5. Very small Philips screwdriver
6. Patience, and possibly an adult beverage
First, flip over your 3-in-1 and locate the small screw in the top left corner. You'll need to unscrew it with
a small Philips screwdriver.
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 2 de 10
Once the screw is out, CAREFULLY pry the front and back of the 3-in-1 apart. Several components are
attached to the casing by sticky stuff, so go slow. You'll see this when you've got it open:
Use your razor to scrape the sticky stuff off the casing as it will probably be in your way later. Set the top
case out of the way and take a gander at the PCB. You'll notice the battery is attached to the board via
two metal tabs.
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 3 de 10
Normally you would remove these and solder on a new battery. BUT, RadioShack doesn't typically carry
CR1220 batteries with tabs, only those without tabs. AND we don't want to solder. So we'll try something
else.
In the previous picture, you'll notice there's a little space between the battery and the connection tab.
Awesome. CAREFULLY stick your razor blade into that gap.
You're going to pry the tab off the top of the battery. Take a deep breath and work the blade across the
battery, underneath the tab. The tab is connected at two small points and with a little twisting of the
razor, you should be able to get them to pop off. When you succeed, you'll see this:
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 4 de 10
Notice that I sort of mangled the top tab. Try to avoid that to ensure a snugger fit when you're finished.
Now you need to disconnect the bottom tab in much the same way as you did the top. This time it's
harder though because you're working UNDER the battery. Go slow. Small twist of the blade. Pop. Pop.
You'll have a better feel for the amount of pressure needed after having removed the top tab.
Grab your new battery and double-check that it matches what you pulled out. Your new battery probably
won't have a rubber coating like your old one, but that's okay. Again, you need a CR1220 3v.
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 5 de 10
To attach the new battery, we need electrical tape. Cut a 1.5-2 inch strip. Now turn it lengthwise and cut
strips down the length of the tape, a few millimeters wide each. Imagine running the tape through a
paper shredder - that's what you're going for. Lay one strip sticky-side-up UNDERNEATH the bottom
battery tab.
Now lay your new battery BETWEEN the tabs with the positive + side up. Try to make the tabs very flat
against the battery so you have a good connection. Fold the tape strip around the battery and make a
good seal. Now, take several more strips of tape and repeat the process from another angle or two until
you're satisfied that the tabs are well connected to the battery. There's no good way to illustrate the
process, so here's the end result:
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 6 de 10
Make sure everything is lined up and then put the casing back together. Replace the screw. Hopefully if
you were careful to not bend the tabs and pressed your tape flat, everything will fit, or bulge only slightly.
All done. Your GBA games should now save just fine. Much cheaper than ordering a new 3-in-1 +
shipping + waiting on delivery.
Post #
Sponsored Links
ShopTemp.com
FileTrip & GBAtemp's Partner Shop now open!
Amazing deals, free shipping, loads of cool gadgets and
flashcarts!
- Acekard 2i: under $15
- R4 DS Revolution: $6 only
- Supercard DSTWO: under $35
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 7 de 10
Group: Members
Posts: 1,720
Joined: 9-May 07
From: NYC, USA
Member No.: 79,174
Advanced Member
Group: Newcomers
Posts: 81
Joined: 14-December 05
Member No.: 34,326
Group: Members
Posts: 3,501
Joined: 23-May 08
From: [@N@[)@ YEAH Group:
Banned!
Member No.: 126,352
GBAtemp Fan
Group: Members
Posts: 494
Joined: 11-August 08
Member No.: 133,031
GBAtemp Regular
On the EZ Forums the best we would work out was to de-solder the blighter! Excellent skills!
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 8 de 10
Group: Members
Posts: 297
Joined: 22-October 07
From: Kingston upon Hull,
England
Member No.: 107,920
GBAtemp Regular
Group: Members
Posts: 234
Joined: 17-May 08
Member No.: 125,623
GBAtemp Maniac
Group: Members
Posts: 1,443
Joined: 26-December 08
From: Philippines
Member No.: 149,890
Giggdy!
Group: Members
Posts: 815
Joined: 10-February 09
From: New Delhi
Member No.: 157,412
Advanced Member
Group: Newcomers
Posts: 75
Joined: 26-October 08
From: USA
Member No.: 140,144
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 9 de 10
Group: Suspended It might. If you open it up and it has similar metal tabs you should be able to use the same method.
Posts: 1,071
The battery might be different though.
Joined: 10-May 06
From: Norway
Member No.: 39,407
Group: Members
Posts: 2,413
Joined: 16-May 08
Member No.: 125,508
This guide was long overdue, and I'm ecstatic that someone has found a way to replace the battery
Group: Newcomers without soldering. THANKS A LOT!!
Posts: 72
Joined: 12-May 08
Member No.: 124,987
Group: Members
Posts: 1,967
Joined: 2-August 07
From: Portsmouth
Member No.: 92,812
http://gbatemp.net/index.php?showtopic=132872 05/10/2010
GUIDE: Change your EZFlash 3-in-1 Battery (w/ PICS) - GBAtemp.net Página 10 de 10
Post #
Sponsored Links
ShopTemp.com
FileTrip & GBAtemp's Partner Shop now open!
Amazing deals, free shipping, loads of cool gadgets and
flashcarts!
- Acekard 2i: under $15
- R4 DS Revolution: $6 only
- Supercard DSTWO: under $35
- Tons of gadgets and cheap gifts under $5
And much more! Check it out now!
« Next Oldest GBA - Hardware, Devices and Utilities Next Newest » Enter Keywords
7 Pages 1 2 3 > »
0 Members:
Forum Home Go
Privacy Policy
http://gbatemp.net/index.php?showtopic=132872 05/10/2010