Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1.2. Relevant identified uses of the substance or mixture and uses advised against
Intended use Protective for concrete surfaces
The product is not classified as hazardous according to the provisions of Regulation (EC) 1272/2008 (CLP) (and subsequent amendments).
Classification and hazard statements:
Hazard pictograms: --
Warnings: --
Hazard statements:
--
Safety advice:
--
The product does not require labeling of danger in accordance with Regulation (EC) 1272/2008 (CLP) and subsequent amendments.
Based on available data, the product does not contain any PBT or vPvB substances as a percentage greater than 0.1%.
3.2. Mixtures.
Not specifically necessary. It is recommended in any case, observance of good industrial practices.
4.2. Most important symptoms and effects, both acute and delayed.
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 1
SDS:Beton Shield
4.3. Indication of any immediate medical attention and special treatment needed.
GENERAL INFORMATIONS
Cool down with water jets the containers to prevent product decomposition and the development of substances potentially hazardous for health.
Always wear full fire prevention gear. Collect extinguishing water to prevent it from draining into the sewer. Dispose of contaminated water used
for extinction and the remains of the fire according to applicable regulations.
EQUIPMENT
normal clothing to fight the fire, such as a compressed air breathing apparatus open circuit (EN 137), complete with flame retardant (EN469),
flame-resistant gloves (EN 659) and boots for the fire brigade (HO A29 or A30).
If fumes or powders are released into the respiratory protection. These directions are valid both for the workers to work which for emergency
interventions.
Prevent product from entering into drains, surface water, ground water.
Confine using earth or inert material. Remove most of the material and eliminate the remainder using jets of water. The disposal of contaminated
material must be made in accordance with point 13.
Any information on personal protection and disposal is given in sections 8 and 13.
Handle the product after consultation with all other sections of this SDS. Avoid dispersal into the environment. Do not eat, drink or smoke while
handling it.
Keep the product in clearly labeled containers. Store containers away from any incompatible materials, checking section 10.
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 2
SDS:Beton Shield
HAND PROTECTION
Unnecessary.
SKIN PROTECTION
Unnecessary.
EYE PROTECTION
Unnecessary.
RESPIRATORY PROTECTION
Not necessary, unless otherwise stated in the chemical risk assessment.
Emissions from production processes, including those from ventilation should be checked for compliance of environmental protection legislation.
There are no particular risks of reaction with other substances in normal conditions of use.
Under normal use and storage conditions are not predictable hazardous reactions.
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 3
SDS:Beton Shield
12.1. Toxicity.
Based on available data, the product does not contain any PBT or vPvB substances as a percentage greater than 0.1%.
Reuse, when possible. The product residues should be considered special non-hazardous waste.
Disposal must be performed through an authorized waste management firm, in compliance with national and local regulations.
CONTAMINATED PACKAGING
Contaminated packaging must be recovered or disposed of in compliance with national waste management regulations.
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 4
SDS:Beton Shield
Restrictions relating to the product or contained substances pursuant to Annex XVII to Regulation (EC) 1907/2006.
None.
Sanitary checks.
Information not available.
No chemical safety assessment has been processed for the mixture and the substances it contains.
GENERAL BIBLIOGRAPHY
1. Regulation (EU) 1907/2006 of the European Parliament (REACH)
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 5
SDS:Beton Shield
KLINDEX srl S.S. 05 Tiburtina Valeria km 209+200 Manoppello (PE) Italy Tel. +39 085 859 546
Fax +39 085 8599 224 Registro AEE: IT08030000004548 web: www.klindex.it
Last date update June 2015 6