Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
TEST 1
SEMESTER I
SESSION 2017/2018
PROGRAMME : 2 DAE
DURATION : 1 HOURS
Q1. a) With the aid of an appropriate circuit configurations, briefly explain the following
situation;
CONFID
i) The generation of DC signal
ENTIAL
( 3 marks )
ii) The generation of AC signal
( 3 marks )
b) Name three types of DC motors
( 1 marks )
c) Sketch and label completely each of the DC motors stated in Q1 (b) .
( 3 marks )
Q2. A short-shunt compound generator delivers 40 A at 400 V to a resistive load. The armature,
series field and shunt field resistances are 0.14, 0.06 and 180 Ω, respectively. Based upon
this configurations;
Q3 A compound DC motor rated at 415 V, 7 HP, 2500 rpm has armature resistance of 0.16 Ω,
series field resistance 0.15 Ω and shunt field resistance of 200 Ω. The rotational losses are
200 W. The full load line current is 43 A.
2
DAE 32303
Q4. A 150 V shunt motor has the following parameters: Ra = 0.5 Ω, Rf = 150 Ω and rotational
loss 250 W. On full load, the line current is 19.5 A and the motor runs at 1400 rpm.
Determine:
Q5. A step-down transformer is rated 250kVA, 8200/377 V and has the following equivalent
circuit parameter:
a) Find the equivalent winding impedance referred to the low voltage side.
b) Find the equivalent winding impedance referred to the low voltage side
c) Draw equivalent circuit for Q7(a) and Q7(b).
( 20 marks )
Q6. Short-circuit and open-circuit tests were performed on a 10kVA transformer,50 Hz, rated
400V-240V, with the results listed below.
Vsc = 10 V Voc = 240 V
Isc = 10kVA/400V=25A I oc = 4 A
Psc = 120 W Poc = 80 W
a) Find all the necessary parameter according to the given tested data above.
b) Draw the equivalent circuit parameters of the transformer referred to the high side.
c) Draw the equivalent circuit parameters of the transformer referred to the low side.
( 20 marks )