Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
34-6431
OPERATING INSTRUCTIONS
Vibrating Poker
34-6431
In the interests of improving and updating its equipment, ELE reserves the right to alter specifications to equipment at any time
ELE International 2008
1 9907X0053 Issue 1
Vibrating Poker
34-6431
Contents
Section Page
1 General information 3
2 Safety 3
3 Electrical safety 3
4 Installation 4
WEEE Directive
2 9907X0053 Issue 1
Vibrating Poker
34-6431
1 General information
1.1 This manual should be read carefully prior to use of the vibrating poker in order that
all safety procedures are adhered to.
1.2 Avoid corrosive substances coming into contact with the motor assembly.
1.3 Dimensions: 200mm long x 300mm wide x 350mm high : weight 9 Kg.
2 Safety
2.1 The vibrating poker should be used only by trained personnel.
2.2 Only use the switch on the motor to start and stop the vibrating poker.
2.3 ELE assumes no liability for damage caused to the machine or it’s operators by
misuse of the machine.
2.4 Never leave the unit alone when turned on.
2.5 The vibrating poker must not be modified or tampered with. The removal/tampering of
the safety devices will be an infringement to the EEC Safety Standards and ELE
assumes no liability for any subsequent damage.
2.6 The equipment must not be subjected to violent shocks.
2.7 Do not submerge the electric unit into water, concrete or any other liquid matter. Do
not use the machine in presence of flammable liquids or gases. It is advisable not to
expose it to rain.
2.8 Keep the electric motor and vibrator clean, but never wash the motor unit using water.
2.9 The sound output has been checked following the ISO 6081(1986) rules by normal
work, and with the vibrator inside sand/water mix in metal box diam. 50 cm, height 50
cm and at 1m distance.
3 Electrical Safety
This equipment has been tested and is safe to use providing that the proper safety
precautions are observed:
Do not use this equipment in any manner, other than as specified in this user
manual, misuse may result in serious injury to personnel.
Do not attempt to operate the equipment with electrical covers removed.
This equipment must be connected to a protected RCCB electrical system.
Refer to Installation section before installing machine.
Do not operate machine with wet hands.
Never carry the unit by it’s cable or pull the cable to disconnect it from the
socket. Keep the cable away from heat, oil and sharp edges. Inspect the cable
regularly and refer any damage to an authorised service engineer.
When the vibrating poker is used outdoors, only use extension cords intended
for outdoor use and connected to an RCCB protected supply.
Important Note : Please read this entire manual before unpacking, setting up or
operating this equipment. Pay particular attention to all DANGER and CAUTION
statements. Failure to do so could result in serious injury to the operator, or other
personnel, or damage to the equipment.
3 9907X0053 Issue 1
Vibrating Poker
34-6431
4 9907X0053 Issue 1
Vibrating Poker
34-6431
5 9907X0053 Issue 1
DIRECTIVE ON WASTE ELECTRICAL & ELECTRONIC EQUIPMENT (WEEE)