www.alliancelaundry.com January 2017 Table of Contents
Title Page
Parts Ordering Information........................................................................................................................................ 2
Serial Plate Location ................................................................................................................................................. 2 Model Identification ................................................................................................................................................... 3 Assembly Drawings .................................................................................................................................................. 4 Parts Lists ................................................................................................................................................................. 9
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
Parts Ordering Information If literature or replacement parts are required, con- For technical assistance, call either of the num- tact the source from whom the machine was pur- bers listed below: chased or contact Alliance Laundry Systems at (920) 748-3121 Ripon, Wisconsin (920) 748-3950 for the name and address of the nearest authorized parts distributor. +32 56 41 20 54 Wevelgem, Belgium
Serial Plate Location
When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on serial plate(s).
Roller Length 160 and 200 cm, diameter 30 cm with fan or without fan, with or without roller speed regulation REF PART NO. DESCRIPTION COMMENTS 27 GRA540405000042 Counter Screw Plate 8 required 30 GRA550000000067 Basin Motor and Bear Box Support 31 GRA550000000085 Door Microswitch Support 32 GRA540200502515 Microswitch Insulating Layer Same as Item 110; 5 required 33 GRA54-GI-651130 Microswitch 4 required 34 GRA540751000029 Automatic Reset Thermostat Optional; 2 required 35 GRA540751000028 Manual Reset Thermostat 2 required 36 GRA540751000025 Emergency Button 2 required 37 GRA540751000026 Emergency Label 2 required 38 GRA540751000024 Contact and Nut 2 required 39 GRA540751000027 Only Contact Normally Closed; 2 required 40 GRA550000701007 Bush for Safety Bar Shaft 2 required 45 GRA540601000041 Control Panel without Speed Control 160 cm; Length - 130 mm 45 GRA540601000043 Control Panel without Speed Control 160 cm; Length - 130 mm custom 45 GRA540601000026 Control Panel without Speed Control 160 cm; Length - 150 mm custom 45 GRA540601000020 Control Panel wtih Speed Control Length - 150 mm 45 GRA540601000042 Control Panel with Speed Control Length - 130 mm 45 GRA540601000044 Control Panel with Speed Control Length - 130 mm custom 45 GRA540601000028 Control Panel with Speed Control Length - 150 mm custom 46 GRA540601000022 Control Board without Speed Control 160 cm 46 GRA540601000024 Control Board with Speed Control 47 GRA540751000021 Probe 48 GRA550751000280 Radio Interference Filter Through Serial No. J0225002605 49 GRA550000701064 Chain Length - 770 mm 50 GRA550000701062 Ring Gear 51 GRA550000751051 Roller Motor 0,37Kw 52 GRA550000751056 Motor Gear Box 0,37Kw 53 GRA550751000052 Motor Gear Box 160 cm; 0,18Kw 54 GRA550751000050 Roller Motor 160 cm; 0,18Kw 54 GRA540651000051 Roller Motor 160 cm; 0,18Kw; 60 Hz 55 GRA550000000031 Roller Pinion Spacer 56 GRA540405007820 Key 57 GRA550000701081 Pinion 57 GRA550000701082 Pinion 60 Hz Models without Speed Control 58 GRA4PR349000032 Lamp Optional 59 GRA550000000068 Roller Motor Bracket 160 cm; 0,18Kw 59 GRA550000000069 Roller Motor Bracket 0,37Kw 60 GRA550000000080 Electrical Component Plate 61 GRA540751000045 Inverter Entity Through Serial No. J0225002605 62 GRA540751000041 Filter Starting Serial No. J0225002606 63 GRA50-851000284 Transformer 320 VA with inverter 64 GRA50-851000265 Thermal Relay 380-440/3ph VAC; 220-230/3ph VAC 50 Hz; 2 required 64 GRA50-8510002654 Thermal Relay 220-230/3ph VAC 50 Hz and 60 Hz; 2 required 65 GRA50-85100283 Transformer 50 VA without inverter
Roller Length 160 and 200 cm, diameter 30 cm with fan or without fan, with or without roller speed regulation REF PART NO. DESCRIPTION COMMENTS 96 GRA540405007820 Key 97 GRA540405007840 Key 98 GRA550000701063 Ring Gear Through Serial No. J0225000946 98 GRA550000701061 Ring Gear Starting Serial No. J0225000947 99 GRA550016000033 Movement Support Shaft 160 cm; Through Serial No. J0225000946 99 GRA550016000034 Movement Support Shaft 160 cm; Starting Serial No. J0225000947 99 GRA550020000033 Movement Support Shaft 200 cm; Through Serial No. J0225000946 99 GRA550020000034 Movement Support Shaft 200 cm; Starting Serail No. J0225000947 100 GRA550000701072 Ball Bearing 2 required 101 GRA550000000030 Gas Springs Bracket Suction Side Through Serial No. J0225000946 102 GRA550000000023 Gas Springs Bracket Through Serial No. J022500946 103 GRA543014000300 Chain Length - 750 mm; Through Serial No. J0225000946 103 GRA550000701065 Chain Length - 721,5 mm; Starting Serial No. J0225000947 104 GRA543014000500 Pinion 105 GRA540405006620 Key 106 GRA550000000022 Basin Movement Spacer 107 GRA550000751052 Basin Reduction Gear 108 GRGRA540651000050 Basin Motor 0,18 Kw, 50/60 Hz 109 GRA550000000089 Phase Microswitch Support Bracket Starting Serial No. J0225000947 110 GRA540200502515 Microswitch Insulating Layer Same as Item 32; 5 required 111 GRA50-GI-951021 Limit Microswitch 2 required 112 GRA55000000066 Actuator for Syncro Microswitch Through Serial No. J0225000946 113 GRA543014002601 Microswitch Bracket Through Serial No. J0225000946 114 GRA550000000082 Microswitch Support Bracket Through Serial No. J0225000946 120 GRA550751000012 Heating Element 160 cm; 2,2/2,5kW; 6 required 120 GRA550751000013 Heating Element 200 cm; 2,8/3,1kW; 6 required 120 GRA550751000014 Heating Element 200 cm; 3/3,4kW; Optional; 6 required 121 GRA550000000098 Heaters Holder Springs 14 required for 160 cm; 18 required for 200 cm 123 GRA540205001440 Thermal Insulation 160 cm 123 GRA540205001840 Thermal Insulation 200 cm 130 GRA550000000008 Basin Movement Lever 131 GRA550000000009 Basin Movement Lever 132 GRA540401300650 Brass Safety Screw Through Serial No. J0225000946 140 GRA550000701080 Ball Bearing 2 required 141 GRA550000000024 Roller Support 142 GRA550000000025 Outer Roller Support Flange 2 required 143 GRA550000000047 Roller Closing Plug 144a GRA550000000012 Plastic Roller Centering Ring 2 required 144a GRA550000000014 Aluminum Roller Centering Ring 2 required 144b GRA550000000018 Aluminum Half Ring 2 required 145 GRA550000701014 Suction Tube 146 GRA550000751055 Complete Fan and Housing Assembly 50/60 Hz 147 GRA550000751054 Extracting Motor 0,12 Kw, 50/60Hz
Roller Length 160 and 200 cm, diameter 30 cm with fan or without fan, with or without roller speed regulation REF PART NO. DESCRIPTION COMMENTS 150 GRA53-GI-100011 Steel Wool Band No spring press cover; 5 required for 160 cm; 8 required for 200 cm 151 GRA54-GI-701015 Jute Sheet 160 cm; Without fan version 152 GRA54-GI-701016 Flannel Layer 160 cm; Without spring press cover 152 GRA54-GI-701019 Flannel Layer 200 cm; Without spring press cover 153 GRA54-GI-701017 Cotton Sheet 160 cm 153 GRA54-GI-701020 Cotton Sheet 200 cm 153 GRA54-GI-701035 Nomex Sheet 160 cm 153 GRA54-GI-701038 Nomex Sheet 200 cm 154 GRA540100000500 Metal Net Fan option without spring press; 5 required for 160 cm; 6 required for 200 cm