On/Off Programme duration figures (guideline) are valid
for maximum temperature wash with no special functions.
❉ : option / Yes: dosing required
1) Do not use liquid detergents.
Max. Detergents and additives Options Tempe- Maximum Programme
load rature Spin time Prewash Main Softener Bleach Half Intensive Speed approx. Programme Type of wash / Notes Wash Load Wash 90° kg °C rpm min. Heavily soiled sheets, tablecloths, underclothes, shirts etc. in hard wearing and high temperature Cotton with Prewash resistant cotton. 5.0 Yes 1) Yes ❉ ❉ ❉ ❉ 60/90* 500 130 The maximum load for heavily soiled washing is 3.5 kg. Moderately soiled sheets, tablecloths, underclothes, towels etc. in hard wearing and high temperature 1) Cotton resistant cotton. 5.0 Yes ❉ ❉ ❉ ❉ 60/90* 500 115 Averagely soiled blouses, shirts etc. made of polyester (Diolen, Trevira); polyamide (Perlon, Nylon), or 1) Coloured cotton blends. 2.0 Yes ❉ ❉ 60 500 100 Lightly soiled shirts, blouses etc., made of polyester (Diolen, Trevira), polyamide (Perlon, Nylon) or 1) Synthetics cotton blends. 2.0 Yes ❉ ❉ 40 500 70 This programme allows starch or softener to be added. 1) Rinse + Spin It is followed by an intensive spin cycle. 5.0 ❉ ❉ Cold 500 20 1) Spin Programme for intensive spin cycle. 5.0 500 15 1) Delicate Delicate fabrics and curtains (dresses, skirts, shirts, blouses, etc.). 1.5 Yes ❉ 40 500 55 Machine washable woollens with pure new wool label. 1) Wool If the Rinse Hold option is selected don't leave the wash to soak for too long. 1.0 Yes ❉ 40 500 45 This programme allows starch or softener to be added. 1) Rinse + Spin It is followed by a gentle spin cycle. 1.5 ❉ Cold 500 15 1) Spin Programme for gentle spin cycle. 1.5 500 10 Drain only, without spin cycle. 1) Drain Alternative way to end programmes after a Rinse Hold. 5 * For obtaining the 90° C temperature, press the “Intensive Wash” option button. N.B. This machine is controlled by sensors. Please avoid excessive detergent dosing. Whirlpool is a registered trademark of Whirlpool USA.
5019 312 10010
ENERGY AND WATER CONSUMPTION DATA PROGRAMME START TO STOP, RESET A PROGRAMME BEFORE THE END Programme Temperature Load Water Energy Programme time Open the water inlet tap and press the On/Off 1. Press the On/Off button to switch off the button. The pilot lamp lights up. appliance. (°C) (kg) (l) (kWh) (min) The pilot light goes out. DOOR LOCK 2. Set the programme selector on Drain. Cotton 90 5.0 72 1.80 115 Cotton 60 5.0 72 1.15 115 During the running programme, the door cannot be 3. Press the On/Off button to start the Drain opened. programme. Coloured 60 2.0 66 0.80 100 The door locks automatically in all programmes. Only open the door when the programme Coloured 40 2.0 66 0.40 100 selector is at STOP and the door is unlocked If the programme is stopped or if an electrical Synthetics + 1/2 Load 30 1.0 54 0.30 70 power failure occurs, the door unlocks (after approximately 1 minute). Delicate 40 1.5 70 0.65 55 automatically after about 1 minute. NOTES AND INDICATIONS FOR USE Wool 40 1.0 70 0.55 45 PROGRAMME END Prewash cycle increases programme duration approximately 15 min. Consumption values were measured in normalized After switching your washing machine on, it conditions in compliance with standard IEC 60 456. Consumption data in the home may vary with respect to the values in The programme selector knob is at STOP, the does not start immediately: it needs some the table in relation to the water supply pressure and temperature, the load and the type of wash. The data on the Energy pilot lamp lights. seconds in order to lock the door, fill water and Label refer to the programme Coloured Cotton 60°C. 1. Press the On/Off button. The pilot light then drum starts turning. * The remaining time indicator can similarly deviate from the values in the table, because it takes into account the household conditions applicable at that time. goes out. Spinning has an interrupted start-up: the drum **To reduce the water temperature, some cold water is added at the end of the main wash cycle, before the pump drains 2. Cancel the options by pressing the appropriate starts and stops running several times, to the water out. buttons. improve spin efficiency and to better balance PREPARATION OF WASH CYCLE PRESS ANY DESIRED OPTION BUTTON(S) 3. Turn the water supply tap off. the laundry. 4. Wait for the door to unlock (about 1 minute). At the end of the spinning cycle the drum goes 1. Close the drum flaps and check that they are Half Load button 5. Open the door and the drum flaps and unload on reversing for some minutes: this helps you properly locked. Reduces the water consumption in the Cotton the machine. unloading the laundry. 2. Add detergents and additives into the dispenser and Synthetics programmes especially during Do not exceed in detergents dosage: excessive to no more then the MAX level mark, as the rinse. SELECTING A NEW PROGRAMME, SPIN SPEED, foam formation may prevent spinning. OPTIONS AFTER PROGRAMME START follows: Especially suitable for lightly soiled or small loads Programme with pre and main wash (reduces the quantity of detergent). 1. Press the On/Off button to switch off the Main wash programme without prewash Not suitable for high temperature programmes. appliance. Fabric softeners and conditioners Intensive Wash 90° button The pilot light goes out. This option allows to put the washing 2. Select the new programme and options. Chlorine bleach temperature to 90° C instead of 60° C for the 3. Press the On/Off button to switch on the Stain remover agents appliance. Cotton programmes. Anti-scale agents (if necessary) The pilot light lights. Especially suitable for heavily soiled laundry. 3. Turn the programme selector knob clockwise to the desired programme.
Whirlpool is a registered trademark of Whirlpool USA.
Wireless Energy Transfer or Wireless Power Is The Transmission of Electrical Energy From A Power Source To An Electrical Load Without Artificial Interconnecting Conductors