Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
com
Tentative
IPS Alpha Technology, Ltd.
TECHNICAL DATA
AX080B058G
CONTENTS
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2601 AX080B058G Page 1-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
RECORD OF REVISION
The upper section : Before revision
The lower section : After revision
Date Summary
Sheet No. Page
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2602 AX080B058G Page 2-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
DESCRIPTION
The following specifications are applied to the following TFT module.
Note : Inverter for back light unit is built in this module.
General Specifications
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2603 AX080B058G Page 3-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Note 1) Temperature and Humidity should be applied to the glass surface of a TFT module,
not to the system installed with a module.
The temperature at the center of rear surface should be less than 70͠ on the condition of operating.
The brightness of a CCFL tends to drop at low temperature. Besides, the life-time becomes shorter
at low temperature.
2) Ta҇40 ̕̕̕͠Relative humidity should be less than 85%RH max. Dew is prohibited.
Ta㧪40 ̕̕̕͠Relative humidity should be lower than the moisture of the 85%RH at 40͠.
3) Frequency of the vibration is between 15Hz and 100Hz. (Remove the resonance point)
4) Pulse width of the shock is 10 ms.
5) Long operation under low temperature may cause some portion of display area to be reddish for
ޓseveral minutes after turning on the product.
ޓHowever, it does not affect the characteristics and reliability of the product.
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2604 AX080B058G Page 4-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2605 AX080B058G Page 5-1/2
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Ǿ
Ǿ㧩q
Ǿ㧩q: :㧔Q ENQEM㧕
㧔Q ENQEM㧕
6(6.%/
< ; Ǿ㧩q
2) Definition of Contrast Ratio (CR) 㧔Q ENQEM㧕
(Luminance at displaying WHITE)
CR=
(Luminance at displaying BLACK)
㩼
Optical 㪈㪇㪇
Response 㪐㪇
( Luminance)
㪈㪇
㪇
4䋩 Definition of Brightness Uniformit Display pattern is white (255 level) . The brightness
uniformity is defined as the following equation. Brightness at each
10% (1) (2) (3) 50%
point is measured, and average, maximum and minimum
90%
(4) (5) (6)
brightness is calculated.
(7) (8) (9) Bmax or Bmin - Bave
Buni㧩 ×100
Bave
10%
50%
90%
where, Bmax = Maximum brightness
Bmin = Minimum brightness
䋺measuring points
㪐
㰿㩷㩿㪙㩿㫂㪀㪀
Bave 㧩Average brightness= 㫂㪔㪈
䋹
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2605 AX080B058G Page 5-2/2
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
3. ELECTRICAL CHARACTERISTICS
3.1 TFT-LCD Module Ta=25͠ޔVss=0V
ITEM SYSTEM Min. Typ Max න ⠨
Power supply Voltage 㨂䌄䌄 11.4 12.0 12.6 㨂
Power supply Current 㧵䌄䌄 - 0.39 0.6 㧭 1),2)
Ripple voltage of power Supply 㨂䌄䌄䌒 - - 350 m㨂
㪫㪝㪫㩷㪤㫆㪻㫌㫃㪼
㪛㪚㩷㪘㫄㫇㪼㫉㪼 㩷㪤㪼㫋㪼㫉
䌖㪛㪛
䌖㪪㪪
2) Current fuse is built in a module. Current capacity of power supply for VDD
should be larger than 4A, so that the fuse can be opened at the trouble of electrical circuit of module.
Note 3)This characteristics should be applied putting on the lamp about 60 minutes later
with ambient temperature. (Ta=25͠±2͠㧕
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2606 AX080B058G Page 6-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
4. BLOCK DIAGRAM
(1) TFT Module
Source
Gate Driver
Timing signal
TFT-LCD
CN2
DC power supply
Lamp8
Back light
ON/OFF Control Lamp7
Error Signal
Lamp 2
Lamp 1
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2607 AX080B058G Page 7-1/1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-1/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
1 Vin
2 Vin
3 Vin Power supply ( Typ. +24.0V ) 1)
4 Vin
5 Vin
6 Vss
7 Vss
8 Vss GND ( 0V ) 2)
9 Vss
10 Vss
11 FAIL Status output (Normal:GND abnormal:open )
12 ON/OFF High : LAMP ON(3.3V) Low : LAMP OFF
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-2/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
CN1
TV set Side TFT-LCD ModuleSide
Rx 0+
TxIN RxOUT
Rx 0- 100
R0-R7 R0́R7
G0-G7 Rx 1+ G0́G7
100
B0-B7 Rx 1- B0́B7
Rx 2+
Rx 2- 100
Rx 3+
DE Rx 3- 100 DE
CLK+
DCLK
PLL CLK- 100 PLL DCLK
Host Timing
Graphics Converter
Controller
Timing Converter
Notes 1) The system must have the transmitter to drive the module.
2) LVDS cable impedance shall be 50 ohms per signal line or about 100 ohms per twist-pair line
when it is used differentially.
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-3/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-4/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Display data of adjacent one pixel is latched during one cycle of DCLK.
㧔㧘㧕
㫇㫀㫏㪼㫃㩷 㧦 㪩㪇㨪㪩㪎 㪑㪩㩷㪻㪸㫋㪸
㩷 㪞㪇㨪㪞㪎 㪑㪞㩷㪻㪸㫋㪸
㪙㪇㨪㪙㪎 㪑㪙㩷㪻㪸㫋㪸
$㪩 ) 㪙4
㨪
㨪
&%.-
4㨪4
㨪
㨪
㨪
㨪
㨪
㨪
㨪
㨪
&6/)
㩷㪛㪜
㨪
㨪
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-5/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2608 AX080B058G Page 8-6/6
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
6. INTERFACE TIMING
6.1 LVDS receiver timing
㫋㪩㪧㪉
㫋㪩㪧㪊
㫋㪩㪧㪋
㫋㪩㪧㪌
㫋㪩㪧㪍
㫋㪩㪧㪇
㫋㪩㪧㪈
㪩㫏㪇 㪞㪉 㪩㪎 㪩㪍 㪩㪌 㪩㪋 㪩㪊 㪩㪉 㪭㪻㫀㪽㪽㪔㪇㪭
㪩㫏㪈 㪙㪊 㪙㪉 㪞㪎 㪞㪍 㪞㪌 㪞㪋 㪞㪊 㪭㪻㫀㪽㪽㪔㪇㪭
㪭㪪㪰 㪟㪪㪰
㪩㫏㪉 㪛㪜
㪥㪚 㪥㪚
㪙㪎 㪙㪍 㪙㪌 㪙㪋 㪭㪻㫀㪽㪽㪔㪇㪭
㪩㫏㪊 㪯 㪙㪈 㪙㪇 㪞㪈 㪞㪇 㪩㪈 㪩㪇 㪭㪻㫀㪽㪽㪔㪇㪭
㫋㪚㪣㪢
㪚㪣㪢 㪭㪻㫀㪽㪽㪔㪇㪭
Rx0=(Rx0+)-(Rx0-)
Rx1=(Rx1+)-(Rx1-)
Rx2=(Rx2+)-(Rx2-)
Rx3=(Rx3+)-(Rx3-)
CLK=(CLK+)-(CLK-)
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2609 AX080B058G Page 9-1/3
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
tV
tVD
DE
tH
tHD
DE
I )50Hz
ITEM SYMBOL Min. Typ. Max. UNIT NOTE
Vertical frequency fV 48 50 52 Hz
Vertical period tV 773 860 1000 tH
Vertical valid tVD 768 tH
DE
Horizontal frequency fH - 43 - kHz
Horizontal period tH 1400 1814 2000 tCLK
Horizontal valid tHD 1366 tCLK
II )60Hz
ITEM SYMBOL Min. Typ. Max. UNIT NOTE
Vertical frequency fV 58 60 62 Hz
Vertical period tV 773 773 1000 tH
Vertical valid tVD 768 tH
DE
Horizontal frequency fH - 46.4 - kHz
Horizontal period tH 1400 1833 2000 tCLK
Horizontal valid tHD 1366 tCLK
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2609 AX080B058G Page 9-2/3
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
T3 T8
24V
21.6V
T4 T6
Back light
power supply 0V
VBL
Back light
0V
PWM
1)
T5 T7
Back light
ON/OFF 0V
1)
0.5 㻡 T1 㻡 10 0 㻡 T6
350 㻡 T2 0 㻡 T7
10 㻡 T3 0 㻡 T8
200 㻡 T4 0 㻡 T9
200 㻡 T5 1000 㻡 T10
10 䋼 T11 Unit : ms
Note 1) In all periods, the backlight ON/OFF signal voltage and the PWM signal voltage should be lower than
the backlight power supply voltage.
IPS Alpha Technology, Ltd. Date Mar. 23, 2009 Sheet No. ATD1403 2609 AX080B058G Page 9-3/3
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com