Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1
Physical properties
Appearance Clear colourless liquid
Preheating
The recommended Avoid hot air convec-
preheat temperature tion pre heater set-
measured on the top- tings above 150°C
side of the boards is
100°C-130°C. Preheat slope:
The flux can have typical: 1,5°C/s
temperature (°C)
250
lower preheating T° as min: 1,0°C/s
long as the solvent is max: 2,5°C/s
evaporated before 200
wave contact.
150
100
Wave contact
Typical wave contact be optimal at this 50
Handling
Storage temperature compen- of the solid content
Store the flux in the sation, with the value may only be done by
original packaging, in the IF 2005M den- using T 2005M condi-
tightly sealed at a sity table and may tioner.
preferred temperature only be adjusted with
of +5° to +25°C the T 2005M accord-
ingly. Reuse
Do not mix used and
Density control fresh flux.
The density of the IF Titration check
2005M flux shall be The solids content
checked using the IF value of the IF 2005M
density meter, the flux shall be deter-
value showed by the mined by using the
density meter should Titration Kit for IF
be compared, after 2005M. Adjustments
Test results
conform EN 61190-1-1(2002) and IPC J-STD-004A
Qualitative halide
Silver chromate (Cl, Br) pass J-STD-004A IPC-TM-650 2.3.33
Environmental
SIR test pass J-STD-004A IPC-TM-650 2.6.3.3
Packaging:
IF 2005M is available in the following packages:
D i s c l a i m e r
Because we cannot anticipate or control the many different conditions under which this information and our products may be used, we do not
guarantee the applicability or the accuracy of this information or the suitability of our products in any given situation. Users of our prod-
ucts should make their own test to determine the suitability of each such product for their particular purposes. The product discussed is sold
without such warranty, either express or implied.
Product information in other European languages can be obtained at Interflux® Electronics NV, 9042 Gent. Because we cannot anticipate or control the many
different conditions under which this information and our products may be used, we do not guarantee the applicability or the accuracy of this information or
the suitability of our products in any given situation. Users of our products should make their own tests to determine the suitability of each such product for
their particular purposes. The products discussed are sold without such warranty, either expressed or implied.
Copyright:
INTERFLUX® ELECTRONICS
www.interflux.com