Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Summary
Page Topic
03 – 17 New EGD
18 – 19 Electrical modifications
20 – 22 New Safety Switch RFIT
23 Suction/Return Filter Pressure Sensor
24 - 26 Central Lubrication 2011
27 – 28 New Step Relay
29 - 31 New Sensors for Rotary, Pressure and Angle
32 Chassis Standby Current
33 Autocor Oman
F4
Service area
Password
Symbol colours:
Bar graphs:
F4
F4
After turning the ignition off, settings revert to the default values.
F4
After turning the ignition off, settings revert to the default values.
F4
After turning the ignition off, settings revert to the default values.
F4
F4
Bar charts and error messaging are only active for engines with electronic motor control (EMR).
You can return to the basic screen by pressing the „HOME“ button, but the control stays
in Service Mode. Return to the service screen by press button F4.
00123
F4 F4
F4
00123
F4
00123
F4
F4
F4
If a new actuator has been learned, the safety switch blocks the code of the previous unit. This cannot be
reinstated by a new memorising process. The blocked security code will only be cleared from the switch after
a third code has been learned.
The safety switch can only be operated by the last actuator learned. If the switch recognises a previously
learned actuator during the memorising preparation period, the process stops immediately and the switch
goes into normal operation.
If it does not find the actuator to be learned in the response zone in less than 60 s, it is not activated.
KS 532817
If the pistons block in the end position, on machines with a switch fork the pump should
be switched off and then on again.
On machines with inductive switches, pumping can be re-established by means of the
changeover switch.
Note when installing a new encoder that the shaft marking is rotated through 180°.
If this is not observed, the transfer tube cannot be programmed in.
compatible
MX 28 with BSA 1408E in Oman. Both units are installed in a building The BSA is equipped with a ZMS-
EPS control box and radio contral. The MX has a separate control box. Both machines can be controlled
by radio.