Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Which value must you configure on a device before EIGRP for IPv6 can start running?
A. public IP address
B. loopback interface
C. router ID
D. process ID
Correct Answer: C
1
When you troubleshoot an IPv4 connectivity issue on a router, which three router configuration checks
you
must perform?(choose three)
A. Verify that the router interface IP address IP address is correct.
B. Verify that the DNS is configured correctly.
C. Verify that the router and the host use the same subnet mask
D. Verify that the router firmware is up-to-date.
E. Verify that a default route is configured.
F. Verify that the route appears in the Routing table
Correct Answer: ACF
Which three statements about link-state routing are true? (Choose three.)
A. Routes are updated when a change in topology occurs.
B. Updates are sent to a multicast address by default.
C. OSPF is a link-state protocol.
D. Updates are sent to a broadcast address.
E. RIP is a link-state protocol
F. It uses split horizon.
Correct Answer: ABC
7
What are the possible trunking modes for a switch port? (Choose three.)
A. transparent
B. auto
C. on
D. desirable
E. client
F. forwarding
Correct Answer: BCD
Refer to the exhibit. Which of these statements correctly describes the state of the switch once the
boot process has been completed?
2
A. As FastEthernet0/12 will be the last to come up, it will not be blocked by STP.
B. Remote access management of this switch will not be possible without configuration change.
C. More VLANs will need to be created for this switch.
D. The switch will need a different IOS code in order to support VLANs and STP.
Correct Answer: B
10
When an interface is configured with PortFast BPDU guard, how does the interface respond when it
receives a BPDU?
A. It continues operating normally.
B. It goes into a down/down state.
C. It becomes the root bridge for the configured VLAN.
D. It goes into an errdisable state.
Correct Answer: D
11
3
A. It provides automatic authentication
B. It can carry multiple protocols, including IPv4 and IPv6
C. It encapsulates all traffic in an IPv4 header
D. It uses labels to separate and foward customer traffic
E. It tags customer traffic using 802.1q
Correct Answer: BD
12
13
Refer to the exhibit, you determine that Computer A cannot ping Computer B
Which reason for the problem is most likely true?
14
15
Which three options are switchport configuration that can always avoid duplex mismatch error between
theswitches?
(Choose Three.)
A. set both side on auto-negotation
B. set both sides on half-duplex
C. set one side auto and other side half-duplex
D. set both side of connection to full-duplex
E. set one side auto and other side on full-duplex
F. set one side full-duplex and other side half-duplex
Correct Answer: ABD
16
17
which task must you perform to enable an IOS device to use DNS services?
A. configure a relay agent information reforwarding policy
B. configure manual bindings
C. configure the relay agent information option
D. configure a name server
Correct Answer: B
18
Which feature is config by setting a variance that is at least 2 times the metric?
A. unequal cost load balancing
B. path selection
C. equal cost load balancing
D. path count
Correct Answer: A
19
5
20
21
22
6
23
24
25
26
7
27
28
29
8
30
Which two statements about stacking Cisco switches are true ?(choose two)
A. It enables the administrator to manage multiple switches from a single management interface
B. The administrator can create only one stack of switches in a network which is under the same
administrative domian
C. When a new master switch is elected,it queries the previous master for its running configuration
D. The administrator can add additional switches to the stack as demand increases
E. Each switch manages its own MAC address table
Correct Answer: AD
31
32
33
Which protocol does ipv6 use to discover other ipv6 nodes on the same segment?
A. CLNS
B. TCPv6
C. NHRP
D. NDP
E. ARP
Correct Answer: D
34
9
35
Which two pieces of information can be shared with LLDP TLVs? (Choose two)
A. device management address.
B. device type
C. spanning-tree topology
D. routing configuration
E. access-list configuration
Correct Answer: AB
36
After you configure the ip dns spoofing command globally on a device,under which two conditions is
DNS
spoofing enabled on the device?(choose two)
A. The DNS server queue limit id disabled
B. The ip host command is disabled
C. All configured IP name server addresses are removed
D. The ip dns spoofing command is disabled on the local interface
E. The no ip domain lookup command is configured
Correct Answer: CE
37
Which type of address is the public IP address of a NAT device?
A. outside public
B. inside local
C. inside global
D. inside public
E. outside global
F. outside local
Correct Answer: C
38
10
39
Which command can you enter to verify that a router is synced with a configures time
source?
A. show ntp authenticate
B. ntp associations
C. ntp server time
D. ntp authenticate
E. show ntp associations
Correct Answer: E
40
41
What is the danger of the permit any entry in a NAT access list?
A. It can lead to overloaded resources on the router
B. It can cause too many addresses to be assigned to the same interface.
C. It can disable the overload command.
D. It prevents the correct translation of IP addresses on the inside network.
Correct Answer: A
11
42
Which two benefits can you get by stacking Cisco switches?(choose two)
A. Each switch in the stack handles the MAC table independently from the others
B. You can add or remove switches without taking the stack down.
C. Each switch in the stack can use a different IOS image
D. The stack enables any active member to take over as the master switch if the
existing
master fails.
E. You can license the entire stack with a single master license
Correct Answer: BD
43
Which configuration register value can you set on a Cisco device so that it ignores
the
NVRAM when it boots?
A. 0x2124
B. 0x2120
C. 0x2142
D. 0x2102
Correct Answer: C
44
45
12
Correct Answer: C
46
47
48
Which three statements about IPv6 address fd14:920b:f83d:4079::/64 are true? (Choose three)
A. The subnet ID is 14920bf83d
B. The subnet ID is 4079
C. The global ID is 14920bf83d
D. The address is a link-local address
E. The global ID is 4079
F. The address is a unique local address
Correct Answer: BCF
49
50
13
14