Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
S60A
Technical Graphics
Ordinary Level
Section A
(120 marks)
Monday, 19 June
Morning 9:30 - 12:00
Centre Number
InstrucƟons
QuesƟon Mark
(a) Answer any ten quesƟons in the spaces provided.
All quesƟons carry equal marks. SecƟon A
1
(b) ConstrucƟon lines must be clearly shown.
2
(c) All measurements are in millimetres. 3
SecƟon A - Page 1 of 6
SECTION A. Answer any ten questions. All questions carry equal marks.
In the space provided, make a freehand pictorial sketch of the sports cone shown
2. below.
Colour or shade the
completed sketch.
A________________ B________________
_________________________________________________________________
_________________________________________________________________
SecƟon A - Page 2 of 6
A B
4. Fig. 1 shows a logo for a car clamping
company inscribed in the square ABCD.
Draw the enlarged logo in the given
square ABCD in Fig. 2.
A B
D C
Fig. 1 D C
Fig. 2
A B
D C
Fig. 1 Fig. 2
SecƟon A - Page 3 of 6
7. The outline of a label for a boƩle is shown.
Also shown is a 3D graphic of the label on the boƩle.
A: ______________
B: ______________
A B C D
Fig. 1 Fig. 2
Answer:_______
SecƟon A - Page 4 of 6
The figure shows the incomplete outline of a golf club.
10. Also shown is a 3D graphic of the club.
Complete the drawing of the golf
club by construcƟng a tangent
from point P to the circle C. P
11. Write down any two CAD commands used to create the drawing of the try-square.
12. Twelve students were surveyed about the type of music that they listened to.
• Pop - 6 students
• Rock - 4 students
• R&B - 2 students
SecƟon A - Page 5 of 6
13. Fig. 1 shows a design for a windfarm logo.
The design is based on a regular hexagon and
arcs as shown.
Fig. 2 shows an incomplete drawing of the
design. Complete the drawing showing all
construcƟons.
Fig. 1 Fig. 2
L L1
Fig. 1 Fig. 2
SecƟon A - Page 6 of 6
Blank Page
Blank Page