Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CIRCUIT DESCRIPTION
This circuit provides power to the vane pump assembly with motor.
DTC No. DTC Detection Condition Trouble Area
Conditions 1. and 2. continue for 1 sec. or more: S Open EHPS relay circuit
C1552/52 1. Power steering ECU terminal MH voltage is 2 V or less S EHPS relay
2. EHPS relay is ON S Vane pump assembly with motor
WIRING DIAGRAM
W Vane Pump Assembly
with Motor
4 4
FL Block, 1 1 EHPS 1
B B–G
4A 5 3 W–G P6 MH
J/B No. 1 IA2 4
IG Switch 1 2
1 1A
1 2 5
B–R 4 W–L P7 MRLY
AM1 IG1 R/B No. 3, 1 2 4
B–Y
W–L
J/B No. 3 EHPS Relay
2 3 3 R/B No. 4, J/B No. 4
ALT
1
ECU–IG
1
IG1 Relay
5
1
AM1
2 1
B–R
1 1 1 2 P8 IGB
2
B–L 3
FL 1 3A 3 3 2
W–B
Main 13 P6 PGND
W–B
B
IF1 W–B W–B
B–R
Battery
IE BL BM
F11480
INSPECTION PROCEDURE
OK
2 Check voltage between terminal 5 of R/B No. 4 (for EHPS relay) and body
ground.
LOCK PREPARATION:
R/B No. 4 Remove the EHPS relay from the R/B No. 4.
CHECK:
Measure the voltage between terminal 5 of the R/B No. 4 (for
EHPS relay) and body ground.
OK:
(+) (–) Voltage: 10 – 14 V
OK
PREPARATION:
Remove the EHPS relay from the R/B No. 4.
CHECK:
5 3
Check the continuity between each terminal of the EHPS relay.
1 2 OK:
Terminals 1 and 2 Continuity (Reference value 80Ω)
Terminals 3 and 5 Open
Open 1
CHECK:
5 (a) Apply battery positive voltage between terminals 1 and 2.
(b) Check the continuity between the terminals.
OK:
Terminals 3 and 5 Continuity
3 2
Continuity
Continuity 1
3 2
NG Replace EHPS relay.
F11788
OK
4 Check continuity between terminal 3 of R/B No. 4 (for EHPS relay) and terminal
MH (P6–1) of vane pump assembly with motor connector.
OK