Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 1 of 3
Shutdown SIS
Previous Screen
Troubleshooting
Caterpillar Monitoring System
Media Number -SENR1394-17 Publication Date -01/07/2009 Date Updated -06/07/2009
i03642457
Table 1
Diagnostic Codes For The Caterpillar Monitoring System (MID No. 030) (1)
CID/FMI Description
CID 0096 - Level Sender (Fuel):
FMI 03 Signal voltage above normal or short to +battery
FMI 04 Voltage below normal or short to ground
FMI 08 Signal is abnormal
CID 0096 - Level Sensor (Fuel):
FMI 08 Signal is abnormal
CID 0100 - Pressure Sensor (Engine Oil):
FMI 08 Signal is abnormal
CID 0110 - Temperature Sensor (Engine Coolant):
FMI 04 Voltage below normal or short to ground
FMI 08 Signal is abnormal
CID 0177 - Temperature Sensor (Transmission Oil):
FMI 04 Voltage below normal or short to ground
FMI 08 Signal is abnormal
CID 0248 - Data Link:
FMI 02 Data erratic, intermittent, or incorrect
CID 0263 - Sensor Power Supply:
FMI 03 Signal voltage above normal or short to +battery
FMI 04 Voltage below normal or short to ground
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 25-09-2012
CUSTOM PRODUCT SUPPORT LITERATURE FOR THE 950H WHEEL LOADE... Page 2 of 3
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 25-09-2012
CUSTOM PRODUCT SUPPORT LITERATURE FOR THE 950H WHEEL LOADE... Page 3 of 3
Note: Every machine may not have all of the diagnostic codes that are listed in the preceding table. Also,
every machine may not have all the FMI for a given CID.
Note: The preceding table shows the diagnostic codes for the Caterpillar Monitoring System. When the
Caterpillar Monitoring System is in the service mode, diagnostic codes from the other electronic control
modules are shown on the display area of the Caterpillar Monitoring System. The information from the
diagnostic code is transferred from other electronic control modules via the Cat Data Link to the main
display module. This diagnostic information is shown when the main display module is in the service mode.
The module identifier (MID) indicates the electronic control module that is sending the diagnostic code. The
MID for the Caterpillar Monitoring System is "030". This Service Manual is used for diagnostic codes with
a MID of "030". The MID of other electronic control modules on a particular machine are listed on the
Electrical System Schematic. Troubleshooting information for those diagnostic codes can be found in the
service manual for that system.
Note: When a sensor diagnostic code is present, the corresponding warning for that sensor is also activated
for the operator. For example, if the signal wire for the engine coolant temperature sensor is shorted to the
+battery, then the following actions take place:
The gauge for the engine coolant temperature is indicating in the warning region.
Notice that the second and third above items are the same warning indications that are activated if the engine
overheats.
Copyright 1993 - 2012 Caterpillar Inc. Tue Sep 25 22:22:26 UTC+0100 2012
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 25-09-2012