Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Insulate
your Attic
With Isover G3 Touch
mineral wool insulation
In easy to follow steps
View our
installation
video:
INTRODUCTION OUR PRODUCTS
ISOVER
recommends
Insulation
between and
over joists
Isover insulation
1 between joists
2 Second layer of Isover
1 2 insulation cross
laid over joists
Width
Depth
Treat sockets and downlighters with a socket box and For the first layer of insulation, lift your insulation through
remember to leave a 75mm gap around the cable, where the attic hatch - whilst keeping the packaging on.
these cables can’t be lifted above the insulation. Then cut the insulation to match the width of your joists.
Finally for this step: Starting at the end furthest away from
the attic door, simply roll and friction fit between the joists.
It’s important to ensure your attic space is well-ventilated Once the first layer is completed, you should put on
to prevent a build up of moisture and condensation. the tank cover and make it secure with tape.
For this purpose, we recommend that you leave Then, put on the pipe covers and seal with a
a gap of 50mm between the roofing membrane tape - such as our Vario Multi-tape SL.
and the insulation at eaves of the roof .
It’s a good idea to put a walkway to your tank. When your 1st layer is complete you are
You can do this by: ready for the top up layer.
• Securing timber across the joists Open Heatshield roll and roll out in the opposite direction
across the joists. ensure you join each layer and leave no gaps
• Laying the top of layer of insulation between them
• Then laying a walkable wood board on top
STEP 9 ATTIC HATCH STEP 10 INSTALLATION MOVIE &
TECHNICAL SUPPORT