Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
After replacing the ECU with new one, perform the variant coding. Then, insert the ignition key and perform the
immobilizer coding.
When inserting an ignition key after replacing the immobilizer unit, the ECU transmits the challenge message and
waits for the response message. The immobilizer unit indicator blinks with 0.5 Hz of interval to inform that the
immobilizer unit is not programmed (i.e. newly replaced). In this case, the immobilizer coding should be performed.
EL
Immobilizer Coding
STICS
CONTROL UNIT SELECTION FUNCTION SELECTION
IMMO
1] ECU 1] READ FINGERPRINT
2] TCU “6” 2] IDENTIFICATION
3] ABS / ESP 3] CODING
SPWM
4] AIR-BAG
5] TCCU
CLUSTER
6] IMMOBILIZER
S/W
“3”
AV
KYRON IMMOBILIZER KYRON IMMOBILIZER
WIPER
ENTER TESTER PASSWORD >>>> WARNING <<<<
YES
1 1 4 3 4
R / SENSOR
If you start immobilizer coding procedure,
value of coded key is cleared.
PAS
LAMP
11434
S / ROOF
Continued
S E AT
A / CRUISE
11434
FAIL
OK
Press “ENTER”
ENTER
Continued
EL
ENTER
STICS
IMMOBILIZER CODING IMMOBILIZER CODING
IMMO
KYRON IMMOBILIZER KYRON IMMOBILIZER
1st Key
Turn “OFF” ignition key. Input code to first key.
SPWM
Coding OK
Remove key and insert 2nd key,
and then Turn “ON” ignition key.
Please wait.
CLUSTER
Press “ENTER”
05 Seconds
S/W
All Key Coding OK
ESC
AV
IMMOBILIZER CODING IMMOBILIZER CODING
WIPER
KYRON IMMOBILIZER KYRON IMMOBILIZER
R / SENSOR
Are you sure exit ? CODING END.
Press “ENTER”
PAS
LAMP
S / ROOF
S E AT
A / CRUISE