Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Submitted by
Student Name ID
Md. Delwar Hossain EBTX-150200588
Md. Shariful Islam EBTX-150200587
Supervisor
Solayman Miah
Lecturer
Department of Textile Engineering
Northern University Bangladesh
April 2018
i
Assessment of Crimp Percentage Variation
Among Woven Structures
By
Student Name ID
Md. Delwar Hossain EBTX-150200588
Md. Shariful Islam EBTX-150200587
Supervised by
Solayman Miah
Lecturer
Department of Textile Engineering
Northern University Bangladesh
April 2018
ii
In the name Allah
The most Beneficent
The most Merciful
iii
Letter of Transmittal
28.04.2018
To
Solayman Miah
Lecturer
Department of Textile Engineering
Northern University Bangladesh
Northern University Bangladesh (NUB)
Please be kind enough to evaluate this dissertation with your valued suggestions.
Sincerely yours
................................... ..............................
Md. Delwar Hossain Md.Shariful Islam
ID: EBTX-150200588 ID: EBTX-150200587
iv
Declaration
We, Md. Delwar Hossain (ID: EBTX-150200588), Md.Shariful Islam (ID: EBTX-
150200587), students of Northern University Bangladesh of Department of Textile
Engineering, hereby declare that the thesis entitled “Assessment of Crimp Percentage
Variation Among Woven Structures”, is our own work and has not been printed,
published or submitted as research work, thesis or publication in any form in any
university, research institution, etc. in Bangladesh or abroad.
v
Letter of Approval
This research work entitled “Assessment of Crimp Percentage Variation Among
Woven Structures”, submitted by . Delwar Hossain (ID: EBTX-150200588),
Md.Shariful Islam (ID: EBTX-150200587), of Department of Textile Engineering t, was
carried out under my supervision and has been accepted as satisfactory for the partial
fulfillment of the requirements for the degree of Bachelor of Science in Textile
Engineering (major).
Dated……………………. (Supervisor)
Solayman Miah
Lecturer
Department of Textile Engineering
Northern University Bangladesh
Board of Examination
1) 4)
………………………………….. …………………………………..
(Board Member) (Board Member)
Md. Nasir Uddin Tarifun Akter
Senior Lecturer Lecturer
Department of Textile Engineering, NUB Department of Textile Engineering, NUB
2)
…………………………………..
(Board Member)
SM Tufazzal Haider
Lecturer
Department of Textile Engineering, NUB
3)
…………………………………..
(Board Member)
Sraboni Ahmed
Lecturer
Department of Textile Engineering, NUB
vi
Acknowledgement
At first our gratefulness goes to almighty allah to give me strength and ability to
complete the project and this report. You have made mylife more beautiful. May you
name to exalated, honeord and glorifiend.
Finally Thanks go to my Precious family for their never ending love and inspire at every
stage of my life. without their continuous support I realize that I would not be person I
am right now.
vii
Abstract
The aim of this study was to develop statistical models for the prediction of warp
and weft crimp percentage of cotton woven fabrics. The developed models are
based on the empirical data obtained from carefully developed 60 fabric samples
with different yarn linear densities, fabric densities and weave designs. The
predictability and accuracy of the developed models was assessed by correlation
analysis of the predicted and actual crimp values of another set of 8 fabric samples
which was not used for the development of models. The results show fairly good
capability and accuracy of the prediction models.
viii
Table of Contents
Topics Page No.
Chapter-01 Indroduction 01-05
1.1 Introduction
1.2 Crimp
1.3 Crimp and fabric properties
1.4 Crimp Interchange:
1.5 Objectives:
ix
List of Table
Table Page
No.
15-72
Table
x
List of Figure / Graph
xi
List of Abbreviation
xii