Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
© 2012 Officine Maccaferri S.p.A. - Bologna - Italy - Print: AL.CO.M. (UD) - Project: ideogramma.eu - Photo: Officine Maccaferri Archive
Official football pitch of Serie A - STADIO SILVIO PIOLA Training center MILANELLO
Novara (IT) Milano (IT)
Laying technique
Football pitch
Capo Verde (CV)
• Once the bed layer has been created with the appropriate
gradients, lay the waterproof membrane longitudinally (see fig.1),
overlapping each piece with the next by approximately 15 cm in
a “roof tile” system, working from the two sides of the pitch to the
centre.
• Finally, lay the artificial turf (see fig. 3 - 4) and soak it thoroughly
(see fig. 5).
Football pitch DE HUMILLADERO Rugby pitch MARIA LUIGIA Rugby pitch
Malaga (ES) Parma (IT) Reggio Emilia (IT)
1 2 3 4 5
TERRADRAIN FOOTBALL THE TRADITIONAL DRAINAGE SYSTEM WITH AGGREGATE • Lower costs for the work in terms of material, labour and
A high performance planar geocomposite specially designed for the drainage system beneath artificial Previously, the only system available to drain rainwater from artificial turf pitches consisted of a number of underlying levels of aggregate installation
turf pitches, to replace the traditional solution of aggregates and drainage pipes. of differing sizes, each serving a different purpose (from the top: sand, grit, crushed stone and finally ballast). The overall aggregate • High drainage capacity and excellent resistance to compression
thickness can vary between 21 and 44 cm and the minimum permissible permeability is 1x10-4 m/s (360 mm/h). These levels create an
initial route for rainwater to drain away downwards, where it fills the voids in the aggregate. Given the main direction of the flow, this • Shorter installation time
TERRADRAIN FOOTBALL also provides excellent elastic and rebound performance that are crucial for
system is referred to in the models of the commissioning body (LND) as a Vertical Drainage Foundation. Once the aggregate is saturated,
the safety of sportspeople using the pitch. Predictable ball behaviour and year round operation of the a system of trenches with drainage tubes under the ballast allows the water to be directed to drainage pipes and perimeter collectors. • Rolls extremely practical and easy to handle on the worksite
facility are additional advantages.
• Rolls made to measure for the exact dimensions of the pitch
These characteristics, together with the innovation and production capabilities of Maccaferri BIS Division, • Extremely flexible
Vertical drainage solution with aggregates. Vertical drainage solution with aggregates.
enable TERRADRAIN FOOTBALL to comply with the strict technical requirements of the F.I.G.C. LND Section Oblique drainage layout
• Perfect impact absorption
Main pipe Ø 160 (draining at 180°)
(Italian F.A. National Amateur League) for artificial turf football pitches.
ARTIFICIAL GRASS TURF 2,50
• Working lifespan of over 25 years
Monofilament and pre-fibrillated
4,5 to 6,0 cm high
/12
m • Recyclable product that does not release pollutants into the
Se
10
SAND
co
nd
Thickness 3 cm - Particle size 0,2/0,8 mm 2m
water
Se
pip
m
co
GRIT /12
eØ
nd
10
ary
Thickness 4 cm - Particle size 1,2/1,8 cm
90
3,50
Advantages
pip
Se
(dr
RUBBLE and BALLAST
co
ain
eØ
nd
AGGREGATE TERRADRAIN
ing
thickness 14-37 cm
90
ary
at
(dr
particle 2,8/3,2/4,0/7,0 cm
pip
3,50
27
ain
eØ
0°)
ing
90
at
(dr
27
GEOTEXTILE 250 gr/m2
ain
0°)
ing
RUBBLE
at
27
Around pipe
0°)
Particle size 2,8/3,2 cm
2,50
DRAINAGE PIPE
Main pipe Ø 160 (draining at 180°) NATURAL SOIL
Draining holes 40x40 Main pipe Ø 160 (draining at 180°) Fewer vehicles entering the
Secondary pipe Ø 90 (draining at 270°) Draining hole 100x100 siphoned and diaphragm with
pipe > Ø 200 for final delivery
worksite
TERRADRAIN FOOTBALL THE TRADITIONAL DRAINAGE SYSTEM WITH AGGREGATE • Lower costs for the work in terms of material, labour and
A high performance planar geocomposite specially designed for the drainage system beneath artificial Previously, the only system available to drain rainwater from artificial turf pitches consisted of a number of underlying levels of aggregate installation
turf pitches, to replace the traditional solution of aggregates and drainage pipes. of differing sizes, each serving a different purpose (from the top: sand, grit, crushed stone and finally ballast). The overall aggregate • High drainage capacity and excellent resistance to compression
thickness can vary between 21 and 44 cm and the minimum permissible permeability is 1x10-4 m/s (360 mm/h). These levels create an
initial route for rainwater to drain away downwards, where it fills the voids in the aggregate. Given the main direction of the flow, this • Shorter installation time
TERRADRAIN FOOTBALL also provides excellent elastic and rebound performance that are crucial for
system is referred to in the models of the commissioning body (LND) as a Vertical Drainage Foundation. Once the aggregate is saturated,
the safety of sportspeople using the pitch. Predictable ball behaviour and year round operation of the a system of trenches with drainage tubes under the ballast allows the water to be directed to drainage pipes and perimeter collectors. • Rolls extremely practical and easy to handle on the worksite
facility are additional advantages.
• Rolls made to measure for the exact dimensions of the pitch
These characteristics, together with the innovation and production capabilities of Maccaferri BIS Division, • Extremely flexible
Vertical drainage solution with aggregates. Vertical drainage solution with aggregates.
enable TERRADRAIN FOOTBALL to comply with the strict technical requirements of the F.I.G.C. LND Section Oblique drainage layout
• Perfect impact absorption
Main pipe Ø 160 (draining at 180°)
(Italian F.A. National Amateur League) for artificial turf football pitches.
ARTIFICIAL GRASS TURF 2,50
• Working lifespan of over 25 years
Monofilament and pre-fibrillated
4,5 to 6,0 cm high
/12
m • Recyclable product that does not release pollutants into the
Se
10
SAND
co
nd
Thickness 3 cm - Particle size 0,2/0,8 mm 2m
water
Se
pip
m
co
GRIT /12
eØ
nd
10
ary
Thickness 4 cm - Particle size 1,2/1,8 cm
90
3,50
Advantages
pip
Se
(dr
RUBBLE and BALLAST
co
ain
eØ
nd
AGGREGATE TERRADRAIN
ing
thickness 14-37 cm
90
ary
at
(dr
particle 2,8/3,2/4,0/7,0 cm
pip
3,50
27
ain
eØ
0°)
ing
90
at
(dr
27
GEOTEXTILE 250 gr/m2
ain
0°)
ing
RUBBLE
at
27
Around pipe
0°)
Particle size 2,8/3,2 cm
2,50
DRAINAGE PIPE
Main pipe Ø 160 (draining at 180°) NATURAL SOIL
Draining holes 40x40 Main pipe Ø 160 (draining at 180°) Fewer vehicles entering the
Secondary pipe Ø 90 (draining at 270°) Draining hole 100x100 siphoned and diaphragm with
pipe > Ø 200 for final delivery
worksite
TERRADRAIN FOOTBALL THE TRADITIONAL DRAINAGE SYSTEM WITH AGGREGATE • Lower costs for the work in terms of material, labour and
A high performance planar geocomposite specially designed for the drainage system beneath artificial Previously, the only system available to drain rainwater from artificial turf pitches consisted of a number of underlying levels of aggregate installation
turf pitches, to replace the traditional solution of aggregates and drainage pipes. of differing sizes, each serving a different purpose (from the top: sand, grit, crushed stone and finally ballast). The overall aggregate • High drainage capacity and excellent resistance to compression
thickness can vary between 21 and 44 cm and the minimum permissible permeability is 1x10-4 m/s (360 mm/h). These levels create an
initial route for rainwater to drain away downwards, where it fills the voids in the aggregate. Given the main direction of the flow, this • Shorter installation time
TERRADRAIN FOOTBALL also provides excellent elastic and rebound performance that are crucial for
system is referred to in the models of the commissioning body (LND) as a Vertical Drainage Foundation. Once the aggregate is saturated,
the safety of sportspeople using the pitch. Predictable ball behaviour and year round operation of the a system of trenches with drainage tubes under the ballast allows the water to be directed to drainage pipes and perimeter collectors. • Rolls extremely practical and easy to handle on the worksite
facility are additional advantages.
• Rolls made to measure for the exact dimensions of the pitch
These characteristics, together with the innovation and production capabilities of Maccaferri BIS Division, • Extremely flexible
Vertical drainage solution with aggregates. Vertical drainage solution with aggregates.
enable TERRADRAIN FOOTBALL to comply with the strict technical requirements of the F.I.G.C. LND Section Oblique drainage layout
• Perfect impact absorption
Main pipe Ø 160 (draining at 180°)
(Italian F.A. National Amateur League) for artificial turf football pitches.
ARTIFICIAL GRASS TURF 2,50
• Working lifespan of over 25 years
Monofilament and pre-fibrillated
4,5 to 6,0 cm high
/12
m • Recyclable product that does not release pollutants into the
Se
10
SAND
co
nd
Thickness 3 cm - Particle size 0,2/0,8 mm 2m
water
Se
pip
m
co
GRIT /12
eØ
nd
10
ary
Thickness 4 cm - Particle size 1,2/1,8 cm
90
3,50
Advantages
pip
Se
(dr
RUBBLE and BALLAST
co
ain
eØ
nd
AGGREGATE TERRADRAIN
ing
thickness 14-37 cm
90
ary
at
(dr
particle 2,8/3,2/4,0/7,0 cm
pip
3,50
27
ain
eØ
0°)
ing
90
at
(dr
27
GEOTEXTILE 250 gr/m2
ain
0°)
ing
RUBBLE
at
27
Around pipe
0°)
Particle size 2,8/3,2 cm
2,50
DRAINAGE PIPE
Main pipe Ø 160 (draining at 180°) NATURAL SOIL
Draining holes 40x40 Main pipe Ø 160 (draining at 180°) Fewer vehicles entering the
Secondary pipe Ø 90 (draining at 270°) Draining hole 100x100 siphoned and diaphragm with
pipe > Ø 200 for final delivery
worksite
Laying technique
Football pitch
Capo Verde (CV)
• Once the bed layer has been created with the appropriate
gradients, lay the waterproof membrane longitudinally (see fig.1),
overlapping each piece with the next by approximately 15 cm in
a “roof tile” system, working from the two sides of the pitch to the
centre.
• Finally, lay the artificial turf (see fig. 3 - 4) and soak it thoroughly
(see fig. 5).
Football pitch DE HUMILLADERO Rugby pitch MARIA LUIGIA Rugby pitch
Malaga (ES) Parma (IT) Reggio Emilia (IT)
1 2 3 4 5
Laying technique
Football pitch
Capo Verde (CV)
• Once the bed layer has been created with the appropriate
gradients, lay the waterproof membrane longitudinally (see fig.1),
overlapping each piece with the next by approximately 15 cm in
a “roof tile” system, working from the two sides of the pitch to the
centre.
• Finally, lay the artificial turf (see fig. 3 - 4) and soak it thoroughly
(see fig. 5).
Football pitch DE HUMILLADERO Rugby pitch MARIA LUIGIA Rugby pitch
Malaga (ES) Parma (IT) Reggio Emilia (IT)
1 2 3 4 5