Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
BASIC DATA AT 20°C (1 g/cm³ = 8.25 lb/US gal; 1 m²/l = 40.7 ft²/US gal)
(data for mixed product)
Mass density 1.4 g/cm³
Volume solids 80 ± 2%
VOC (supplied) max. 161 g/kg (Directive 1999/13/EC, SED)
max. 226 g/l (approx. 1.9 lb/gal)
Recommended dry film thickness 125 - 200 µm depending on system *
Theoretical spreading rate 6.4 m²/l for 125 µm *
Touch dry after 3 hours *
Overcoating interval min. 8 hours *
max. 28 days *
Curing time 7 days *
(data for components)
Shelf life (cool and dry place) at least 12 months
* see additional data
page 1/4
SIGMACOVER 380
June 2009
– for shop primer without IMO type approval; blast cleaned to ISO-Sa2
removing at least 70% of intact shop primer, blasting profile 30 - 75
µm
• dust quantity rating "1" for dust size class "3", "4" or "5", lower dust size
classes to be removed if visible on the surface to be coated without
magnification (ISO 8502-3:1992)
– for atmospheric exposure conditions:
• steel; blast cleaned to ISO-Sa2½, blasting profile 30 - 75 µm or
according to ISO-St3
• shop primed steel; pretreated to SPSS-Pt3
• galvanised steel; cleaned from grease, salts, contamination and
roughened up
– previous coat; (e.g. SigmaCover 380) dry and free from any contamination
– substrate temperature should be above 5°C and at least 3°C above dew
point during application and curing
– maximum relative humidity during application and curing is 85%
AIRLESS SPRAY
Recommended thinner Thinner 91-92
Volume of thinner 0 - 10%, depending on required thickness and application conditions
Nozzle orifice approx. 0.46 - 0.53 mm (= 0.018 - 0.021 in)
Nozzle pressure 20 - 25 MPa (= 200 - 250 bar; 2800 - 3500 p.s.i.)
SAFETY PRECAUTIONS for paint and recommended thinners see safety sheets 1430, 1431 and relevant
material safety data sheets
this is a solvent borne paint and care should be taken to avoid inhalation of
spray mist or vapour as well as contact between the wet paint and exposed skin
or eyes
page 2/4