0 valutazioniIl 0% ha trovato utile questo documento (0 voti)
192 visualizzazioni1 pagina
You are configuring port security on a switch to prevent guests from connecting personal laptops to ports hosting a public kiosk display. You configure FastEthernet ports 0/2 through 0/4 as access ports, enable port security to learn and retain the MAC addresses of connected hosts, set the port security violation as protect, and save the running configuration.
You are configuring port security on a switch to prevent guests from connecting personal laptops to ports hosting a public kiosk display. You configure FastEthernet ports 0/2 through 0/4 as access ports, enable port security to learn and retain the MAC addresses of connected hosts, set the port security violation as protect, and save the running configuration.
You are configuring port security on a switch to prevent guests from connecting personal laptops to ports hosting a public kiosk display. You configure FastEthernet ports 0/2 through 0/4 as access ports, enable port security to learn and retain the MAC addresses of connected hosts, set the port security violation as protect, and save the running configuration.
You are configuring a switch that has three hosts attached to FastEthernet 0/2 through 0/4. All three hosts are part of a public kiosk display that allows guests to access the Internet. You would like to implement port security to prevent guests from removing Ethernet cables from the hosts and connecting them to the Ethernet ports on their personal laptops. If guests attempt to connect through their personal laptops, you would like the switch to drop the frames.
Complete the following tasks:
Configure FastEthernet 0/2 through 0/4 as access ports.
On the FastEthernet 0/2 through 0/4, configure port security to learn and retain the MAC addresses of the connected hosts. Configure the port security violation as protect on each applicable interface. Save your changes to the startup-config file.
The switch is currently configured with the default port security settings. Use the show run command to verify the configurations. Start Lab