Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Read out/save SCN coding and EHS# from vehicle using OBDII connector
Set up virgin vgs to fvdi on bench using the obd connector according to the following:
Transfer SCN coding and EHS# you saved into the virgin VGS Replace VGS Plug in old control
module to car(I let it hang from connector) Go into development data in ETC->control unit
adaptations->Read coding and/or transfer download data to new control unit follow the next
steps(it will say that not all coding can be exchanged....(its ok) after you plug back in and it transfers
coding it will say not all data could be exchanged, do you want to do manual settings now? say
later/NO On main ETC page control unit version, make sure your EHS# matches the original
from the control unit version page you printed out, just the EHS# must match, If it does not match
goto development data- control unit adaptations(download) ZBEHS enter the original EHS#
from control unit version sheet you printed at the very beginning of job. 1 means it was transferred ;)
Well, now in the Main ETC page Control unit adaptations control module programming
offline programming hard disk data. (I use a LAN cable with my C4 for this just to make sure
complete programming will be successfully done :P control unit adaptations detach
transport/personalize/activate follow prompted steps.
Done!
Please note that: this process has been proven and tested on cars with VGS2 and newer only.
mhhauto.com ®