Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
T W O - P A R T S O LV E N T F R E E E P O X Y R E S I N B A S E D
BONDING AGENT
Description
Dr. Fixit Epoxy Bonding Agent is a two part solvent free bonding agent composed of liquid epoxy resin and
hardener. It is used for bonding of structural concrete new to old concrete and bonding agent for bricks and steel
components because it gives excellent bonding properties to freshly mixed concrete/mortars, glazed bricks,
tiles, etc.
211 Dr. Fixit Epoxy Bonding Agent
Areas of Application
}} Bonding agent for bonding of old to new concrete / mortar.
}} To extend or repair structural concrete.
}} Bonding agent of glazed brick, tiles, steel & structural members.
Method of Application
1 S U R FAC E P R E PA R AT I O N
}}The surface must be thoroughly cleaned and prepared. Remove all loose particles, dirt, dust, laitance, and
mould release agents, curing compounds, oils, grease, floor hardeners and any waterproofing materials for best
results.
}} emove laitance, dirt and dust by mechanical scarification such as wire brushing, scrapping, scabling or grit
R
blasting.
}} Clean the dust by pressurized air or by washing with water.
}} Oil and grease should be removed by degreasing with solvents like turpentine or thinners.
}} Visible signs of mould growth should be removed & treated with a fungicidal solutions
}} New concrete must be cured completely .
2 M I X I N G
}} Stir the material of both base & hardener containers to a uniform colour & consistency.
}}Transfer the entire quantity of base component into a clean & dry vessel, then poured entire quantity of hard
ener into the base. The two parts must be mixed thoroughly with a low speed mixer (150 to 200 rpm for
about 3 to 4 minutes) to get uniform colour & consistency of the mixed material.
92
Dr. Fixit Epoxy Bonding Agent
BUILDING REPAIRS
T W O - P A R T S O LV E N T F R E E E P O X Y R E S I N B A S E D
BONDING AGENT
3 A P P L I C AT I O N
}} Mixed material should be brushed applied on the prepared surface.
}} Overlay of concrete / mortar has to be placed on Dr. Fixit Epoxy Bonding Agent when it is tacky.
}} In case Dr. Fixit Epoxy Bonding Agent has dried, apply a 2nd coat before placing the concrete / mortar.
Technical Information
Packing
1 kg
Coverage
}}2 – 3 sq meter / kg depending on the substrate.
93
Dr. Fixit Epoxy Bonding Agent
BUILDING REPAIRS
T W O - P A R T S O LV E N T F R E E E P O X Y R E S I N B A S E D
BONDING AGENT
swallowed, do not induce vomiting but call for medical assistance immediately.
}} nsure the pack is available for the medical attendant to examine any relevant instructions and
E
contents details.
}} Reseal all containers after use and ensure product is stored as instructed.
}} Do not smoke when handling this product.
}} Do not inhale.
}} Apply in well-ventilated areas.
}} Apply away from naked flames.
}}Store away from sunlight.
Pidilite Industries Limited DISCLAIMER The product information & application details given by the company
Construction Chemicals Division & its agents has been provided in good faith & meant to serve only as a general
Ramkrishna Mandir Road, Post Box No. 17411 guideline during usage. Users are advised to carry out tests & take trials to ensure on
the suitability of products meeting their requirement prior to full scale usage of our
Andheri (E) Mumbai 400059 INDIA
products. Since the correct identification of the problems, quality of other materials
Tel +91-22-2835 7000 • Fax +91-22-2835 7008
used and the on-site workmanship are factors beyond our control, there are no
website www.doctor-fixit.com • E-mail drfixit@pidilite.com expressed or implied guarantee / warranty as to the results obtained. The company
E-mail drfixitadvice@pilmail.com does not assume any liability or consequential damage for unsatisfactory results,
Dr. Fixit Advice Centre (Toll Free No.) 1800-209-5504
94