Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Jabatan : .
2. Describe the phase relationship across the coupling when parallel misalignment exists.
A. In-phase in the radial direction, and out-of-phase in the axial direction.
B. Out-of-phase in the radial and axial directions.
C. In-phase in the axial direction and out-of-phase in the radial directions.
D. In-phase in the radial and axial directions.
4. If the motor speed was 1480 RPM, and the input gear of the gearbox had 39 teeth, and
the pinion had 15 teeth, and the compressor had 12 vanes, provide the following details:
Gearmesh frequency: ________57720_________ CPM
7. If there is a peak in the spectrum as a result of a resonance, what will happen to the
amplitude of the peak if the machine speed is changed?
A. Nothing, it will remain unchanged
B. It will increase
C. It will decrease
D. It will increase when it is excited
8. Gearmesh is calculated by...
A. Adding the number of teeth on each gear
B. Multiplying the number of teeth on the gear by the speed of that gear
C. Multiplying the number of teeth on the input shaft by the speed of the output
shaft
9. What type of sensor measures the relative movement between the shaft and bearing?
A. Displacement non-contact eddy current probe
B. Velocity sensor
C. Accelerometer
13. What type of phase measurement is used when diagnosing typical machine faults?
A. Absolute phase
B. Relative phase
14. If two sheaves/pulleys are not aligned correctly, the vibration pattern will produce...
A. a strong 1X component in the radial directions
B. a series of harmonics of the belt rate frequency
C. a strong 1X component in the axial direction
D. strong 1X, 2X, and 3X peaks
15. The two-stage gearbox below has the number of teeth on each gear and pinion as
shown. From this information, and the fact that the motor speed is 1450 RPM, calculate
the following information:
Stage one gearmesh frequency: _____1450 X 24 =34800____________ CPM
Speed of intermediate shaft: __________1450 x 24/76 = 458_________ CPM
Stage two gearmesh frequency: _____1450 x 24/76 x 32 = 14653____________ CPM
Speed of output shaft: __1450 x 24/76 x 32/89 = 165______ CPM
16. If a signal of 200 Hz was changing in amplitude at a rate of 20 Hz, you would see...
A. A peak at 200 Hz, 400 Hz, 600 Hz, etc.
B. A peak at 200 Hz and 20 Hz.
C. Peaks at 180 Hz, 200 Hz and 220 Hz.
17. What is the most important factor in selecting the location for the sensor?
A. Good, clean contact with the machine
B. Located on a bearing house with a good mechanical transmission path
C. Good, safe access to the mounting location
D. All of the above
________________________________________________________________________