Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Testing
D
Adhesion Testers
Cross Hatch Cutter
Available in 2 sizes (1mm and 2mm), allows an assessment of the
adhesion resistance of coatings to separation from substrates when a
right-angled lattice pattern is cut into the coating and penetrates through
to the substrate. Can be used on multiple coatings. Precision-ground,
hardened tool steel cutting blades with 6 cutting sides so when 1 cutting side
becomes blunt there are a further 5 cutting sides to use.
Directions for use: Make one cutting pass through to the substrate. This makes
6 cuts in the coating. A second pass at 90º makes a square lattice pattern.
Apply Adhesive Tape over the cut lattice section & within 5 minutes remove
tape. Classify the cut area with a Viewing Lens according to the relevant
national standard classification guide.
Cutters only
1mm Cross Hatch Cutter, for coatings up to 60μm thick
(supplied in carrying case)
2mm Cross Hatch Cutter, for coatings over 60μm thick
(supplied in carrying case)
The adhesion is measured by the tensile pull on a Dolly glued to the coating
surface. The force is applied through the centre of the Dolly by a hydraulically
loaded pin ensuring an exact central point loading of the force. Adhesion
values are recorded by a pressure gauge giving a 1:1 pressure reading.
Supplied with 5 Flat Dollies, Adhesive, Dolly Remover & Carrying Case.
Complies with ISO 8780-5, ISO 787/16, ASTM D 332 & ASTM D 387
Simple to Use
P Pull Rate Indicator allows operator to easily monitor and adjust the rate of pull
in accordance with international test methods.
P Easily select dolly sizes, change measurement units or store readings, with
the touch of a button.
P Conversion charts not required – tester automatically calculates pressure
based on dolly size.
P Inexpensive, single-use dollies eliminate cleaning for re-use and can be kept
as a permanent record.
P Each kit comes with everything needed for testing.
Durable
P Environmentally sealed enclosure – weatherproof, dustproof and shockproof.
P Can be used in any position.
P Rugged carrying case.
P Two year warranty.
Accurate
P Every Adhesion Tester pressure system is calibrated and certified to ± 1%
accuracy using NIST traceable load cell.
P Self aligning aluminum dolly enables accurate measurements on smooth or
uneven surfaces.
P Hi-grade, industrial pressure sensor ensures continued accuracy.
P Conforms to national and international standards including, ISO
4624/16276-1, ASTM D4541/D7234, AS/NZS 1580.408.5 and others.
Versatile
P Internal Memory stores maximum pull-off pressure, rate of pull, test
duration and dolly size.
P Optional software available for downloading.
P LCD displays pressure value in MPa or psi.
P 10, 14, 20 or 50 mm dollies maximize capability and measurement resolution
across a wide range of bond strengths.
Adhesive Kits
Additional adhesive, mixing sticks, palettes and cotton swabs.
Dollies
Additional supplies of 10, 14, 20 and 50mm dollies.