Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Cu-DHP
Industrial Rolled
Alloy Designation Copper Rolled Products
EN Cu-DHP
(SF-Cu)
JIS C 1220
UNS* C12200 We produce a vast assortment of copper rolled products that vary in
chemical composition, size and format, all suited to the many types of
* Unified Numbering System (USA) final processing. KME can offer various types of copper rolled products to
its industrial customers, all with a minimum 99.9% purity:
Main Applications
Architecture Downspouts, Gutters, Flashing, Roofing
Building Heater Units, Condenser Sheets
Consumer Air Conditioners, Refrigerators
Electrical Wire Connectors, Heater Elements
Industrial Construction, Rotating Bands, Kettles, Anodes for Electroplating, Heat Exchanger Shells, Oil Coolers in Airplanes, Tanks,
Casting Molds, LP Gas Service, Medical Gas- Oxygen, Plating Anodes, Plating Racks, Plating Hangers, Marine Oil Coolers
Preferred Applications
xx xx xx xx xx xx
Physical Properties
Typical values in annealed temper at 20 °C (Just for information)
Electrical Conductivity
58
Electrical conductivity is strongly influenced by
56 chemical composition. A high level of cold
deformation and small grain size decrease the
E. Conductivity [MS/m]
50
48
46
44
42
R220 R240 R290 R360
Temper
Fabrication Properties* Corrosion Resistance*
Capacity for Being Cold Worked Excellent Water (industrial and drinking):
up to flow rate of 1,5 – 2 m/s
Capacity for Being Hot Worked Good
at 750 -950°C Pure water vapour
Machinability (Rating 20) Less suitable Industrial atmosphere: under formation of dark green
protective layers.
Capacity for Being Electroplated Excellent
Non oxidizing acids
Capacity for Being Hot-Dip Tinned Excellent
Alkalis: With the exception of ammonia and cyanide-
Soft soldering Excellent containing compounds
Resistance Welding Less suitable Neutral saline solutions
Gas Shielded Arc Welding Excellent Biological properties: ?
Laser Welding Good Household compatibility: ?
Soft annealing 250 - 500°C * For more details call our technical service
Stress relaxation annealing 150 – 200°C
6
Bending test after EN ISO 7438 is done at
bending edge transvers rolling direction 10 mm wide samples. Smaller samples in
5 bending edge in rolling direction general – as well as lower thickness - allow
Bending Radius r/t 90
0 180° parallel
R220 R240 R290 R360
Temper
Bending Properties*
Temper Thickness Bending Bending
Range 90° 180° 90° transverse
Trans- Parallel Trans- Parallel
vers vers
180° transverse
mm R/T R/T R/T R/T
90° parallel
R220 ≤ 0.5 0 0
R240 ≤ 0.5 0 0
R290 ≤ 0.5 0 0
Softening Resistance
0
0s 10 s 30 s 1 min 3 min 5 min 30 min 60 min
Time
©KME Germany GmbH & Co. KG - www.kme.com - info-germany@kme.com
Page 3