Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
material, unique spunlace processing, form a unique wood pulp / polyester structure.
Especially clear for the electronics factory stencil printer, a circuit board and the excess solder
paste red plastic, holding circuit board spotless, thus greatly reducing the scrap rate, greatly im-
prove production efficiency and product quality. In order to improve customer efficiency, cost sav-
ings, effective control of the amount, I can actually use according to the customer, the width and
length of the selected product
Product Features:
1. The natural wood surface and the polyester surface combine tough and durable, with high water
and oil absorption than four times faster than ordinary cotton cloth.
2. The material is soft, clean surface does not have any scratches, do not damage the surface of ob-
jects, can not afford to dust.
3. The cleaning solution can be used with a variety of use.
4. Anti-static packaging for electronic products with strict anti-static requirements;
Specification of core Specification of paper
Machine
ID OD Width Length
Core MM Core type
MM MM MM M
DEK 530 20 24 200-510 10 Plastic
Wipes from 55% cellulose (wood pulp) and 45% polyester blended (non-textile) is made. Wipe clean paper is widely used, it can
be used to: disk drive, composite materials; LED display products; PCB circuit board production lines; medical equipment; preci-
sion instruments; optical products; aviation industry; laboratory; a semiconductor chip production lines, the microprocessor;
semiconductor assembly production line; clean room and production lines.
Size
intelligent automatic shoe cover function to help people dressed shoes, users no longer need to bend by hand in
the feet worn shoe.
Product Features:
1- machine inside the main circuit board controlled by a microcomputer, DC motors, infrared switches, limit
switches, gears and other components. Machine works automatically, without manual assistance.
2. The machines contain multiple sets of infrared detection switch, coupled with the new hidden retractors de-
signed to be effective guarantor of the foot is not clamped to the machine.
防静电台垫 Anti-static table mat
材质:是多种树脂合成而制造的防静电贴面,表面耐磨符合国家标准≥1000转/分
防静电性能:通过国家防静电检测中心检测,采用上下两层传导进行静电泄放,上层灰色(兰色)表面电阻10^8欧,下层表
面电阻≤10^6欧,cm体积电阻≤10^8欧,静电衰减期5000V-500V 时间≤1S.
测试方法:用两重锤放在灰色贴面板表面,间隔距离1cm,湿度45%,温度26度,测得上述电阻值.
Materials: a variety of synthetic resin manufactured antistatic veneer, wear-resistant surface in line with the national
standard ≥1000 r / min
Anti-static properties: anti-static through the national testing center, use upper and lower conductive electrostatic dis-
charge, the upper gray (blue) surface resistance of 10 ^ 8 ohms, the lower surface resistance ≤10 ^ 6 Euro, cm volume
resistivity ≤10 ^ 8 ohms, static decay time of the 5000V-500V ≤1S.
Test Method: The two heavy hammer on gray plywood surface, spacing 1cm, humidity 45%, temperature 26
degrees above the measured resistance value
Cover tape Kapton tape
Micro Wiper
ESD Wrist Band