BILL OF QUANTITIES FOR THE REHABILITATION AND UPGRADING
OF SMOKE DETECTORS, FIRE ALARMS AND OTHER FIRE
FIGHTING EQUIPMENT AT NIMSASA HEAD OFFICE
S/no. Description of work Qty Rate Amount
Demolition and Alterations
A Allow for the removal of all the dilapidated and
damaged smoke detectors
B Allow for the removal of ceiling boards at
various floors where the facilities were covered
C Allow for the removal of the damaged cables and
conduit pipes
CONTROL PANELS.
D Supply, Installation, testing & commissioning of
Addressable 2-Zones fire alarm panel. The panel should consist of 2 x 40 character LCD display battery supervision, flash EPROM memory single walk test, 4 operator access levels, 600 event historical log, zone / point selectable alarm 9 nr verification
E Addressable Fire alarm panel- 2 Loops with Min. 9 nr
99 detectors & 99 devices capacity for each loop.
REPEATER PANEL. / INTEGRATION
WITH BUILDERS PANEL F Integration with Builders existing panel with required control modules. The builder Master panel located at ground floor level. The required Control / Monitoring module and cable to be considered in part of Scope. (Vendor needs to collect the necessary information from Site for the same in consultation with resident project manager.)
Total carried to Summary
SMOKE DETECTORS
A Servicing, relocation, Installation, testing &
commissioning of Intelligent Addressable smoke detector complete with base, locking etc. LED with twin indicators for normal working & on alarm condition. (Make: Same as Alarm panel) B Decking ceiling 215 nr
C Below suspended ceiling 45 nr
POWER SUPPLY UNIT
D Supply, Installation, testing and commissioning
of required power supply units to be provided for hooter cum strobe. (Instead of external power unit, providing additional power supply modules inside the panel is acceptable)
JUNCTION BOXES
E Repair, Supply & Installation of Junction Boxes
to fix the smoke detectors
RESPONSE INDICATORS:
F Supply, installation, testing and commissioning
of Response Indicators with Single LED 10 nr
MANUAL CALL POINT
G Analogue addressable pull down type manual call
point with address selection through dip-switch. 20 nr manual call point(break glass)
LOOP SOUNDERS
H Servicing, Installation, testing & commissioning
of addressable loop sounder. (Strobe cum loop sounder) (Alternatively providing control module for addressing the same instead of loop sounder is acceptable, one control module for one sounder). 9 nr .
Total carried to Summary
WIRE / CABLE
A Supply, Installation, testing & commissioning of
2Cx1.5mm2 Armoured Copper conductor cable. The rate shall include all necessary cable glands, lugs etc. 750 mtrs
B 3 Runs x 1.5 mm2 Copper conductor wire in MS
Conduit. 350 mtrs
C 25 x 25 cable termination box with connectors &
rail arrangement for terminating of cables in different floors 20 mtrs
D Supply, Installation, testing & commissioning of
8Cx1.5mm2 Armoured Copper conductor cable. The rate shall include all necessary cable glands, lugs etc. 100 mtrs
FIRE HYDRANTS
E Allow for the clearing and servicing of hydrant
pipe ( supply and distributions)
F Allow for the servicing and replacement damaged
hydrant hoses
G Cleaning and replacement of chemicals in the
overhead hydrant tank
H Allow for the builders’ work at the areas affected