Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
+ 2Ω - 1Ω 4Ω
Vx -
3V 3Ω 1Ω 6.5Vx
+
+
- 4ix
2Ω 8Ω
4Ω 3Ω 5Ω
b) Find the inductance of a coil in which a current increases linearly from 0 to 0.2A in 0.3secs
producing a voltage of 15V [2M]
c) For the given circuit if the current I= 3A & 1.5A for RL= 0 Ω & 2Ω respectively then what is the
value of I for RL=1Ω? R [3M]
V RL
3a) Find the average & RMS values of the waveform [4M]
10V
T(sec)
0.01 0.02
b) Find in magnitude & phase the voltage across & current through each element if the circuit of
two coils A & B are connected in parallel to a 100V, 50 Hz supply .The coil A has 6 Ω resistance & 8Ω
inductance & coil B has 6 Ω resistance & 8 Ω capacitance . Also find the total current , power & p.f of the
circuit .Also draw the phasor diagram showing all the quantities [6M]
b) A RLC series circuit has a current which lags behind the applied voltage by 45 degrees .The voltage
across inductance has maximum value equal twice the maximum of voltage across capacitor . The
voltage across inductor is given by 30sin1000t . If R=20 ohms find the values of L &C [6M]
5 a) In the circuit shown find the thevenin’s equivalent circuit at terminals A& B [6M]
9Ω
A 6Ω 7.5Ω
1.5Ω 5Ω 30V
12A 6A
120 V 6A 6A
6 Using principle of superposition calculate the current in 4Ω resistor in the network [10M]
5Ω 4Ω 2Ω
R [6M]
(30+j40)Ω (15+j12)Ω
3 220V
B (8-j14)Ω
b) Two coupled coils with L1=0.01H & L2=0.16H & K =0.5 has N2 = 1000 Turns .The current in
coil 1 is i1=10sin 400t .Determine the voltage at coil 2 & maximum flux set up by coil1
[4M]
8 a) For the circuit shown in fig find the voltage across j5 Ω reactance [5M]
3Ω j4Ω
J3Ω
b) Each phase of 3 star connected load consists of pure resistance of 100Ω in series with a capacitance
of 31.8μF capacitor .Calculate the power absorbed ,total KVA & p.f when connected to a 400V 3 phase
50HZ supply [5M]
9 For the circuit shown in fig determine the current at any time t>0.The switch is closed at t=0.Assume
no initial charge on the capacitor Use classical method [10M]
S1
0.2H
20Ω
150sinwt
20μF
10 The switch in the circuit shown below has been closed for a long time .When switch is opened at
t=0
10Ω 50Ω