Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Pro/ENGINEER
Mechanical Engineering
Tutorial 4
Home • Course Info • Tutorials • Problems • Students • References
Introduction
The ability to modify and manipulate features is important technique in Pro/E. In this section, you will learn how to use the model tree
to modify various aspects of a feature.
Feature Modification
[Figure 4.1]
www.me.cmu.edu/…/tutorial4.htm 1/7
2/22/2010 Tutorial 4
[Figure 4.2]
www.me.cmu.edu/…/tutorial4.htm 2/7
2/22/2010 Tutorial 4
[Figure 4.3]
13. Select [Regenerate]. You should notice that dimension sd1 has changed from 180 to 160.
14. Select [Modify] from the SKETCHER menu.
15. Select dimension sd0 and change it to 220.
16. Select [Regenerate]. You should notice that both dimension sd0 and sd1 change, as shown in Figure 4.4.
www.me.cmu.edu/…/tutorial4.htm 3/7
2/22/2010 Tutorial 4
[Figure 4.4]
www.me.cmu.edu/…/tutorial4.htm 4/7
2/22/2010 Tutorial 4
[Figure 4.5]
21. Next a round will be added to the edges on the other side of the part. Right click on the Round branch of the model tree and
select [Edit Definition].
22. Rotate the part so that you can see the edges which have not been rounded.
23. Use the left mouse button to select Edge1, Edge2, and Edge3 shown in Figure 4.6.
www.me.cmu.edu/…/tutorial4.htm 5/7
2/22/2010 Tutorial 4
[Figure 4.6]
24. Click the check button, and rotate the part to make sure all edges are rounded. You should see the image shown in Figure 4.7.
www.me.cmu.edu/…/tutorial4.htm 6/7
2/22/2010 Tutorial 4
[Figure 4.7]
www.me.cmu.edu/…/tutorial4.htm 7/7