Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
DRILL STRING
CASING
HYDRAULIC OR MECHANICAL
SETTING TOOL RELEASED FROM
ADAPTER
BUMPER SUB
CHANCELLOR HYDRAULIC OR
MECHANICAL DRILL-IN ADAPTER
AND SETTING TOOL
BLANK LINER
PERFORATED LINER
TUBING STINGER
TUBING STINGER PICKED UP TO
CLEAR PACKOFF
OPENED HOLE
BIT
DRILLING IN TOOLS RELEASED AND CIRCULATING TOOLS OUT AND SCA SET
The Chancellor drill-in assembly is used when drilling in a new liner with or without a pilot or previously drilled hole. This system of drilling-in
liners has proven especially beneficial for liner work over in older, depleted, unconsolidated reservoirs or where returns or sloughing of sand is
a problem. The assembly is used for new completions as well as redrills. The mechanical type drill-in adapter has sufficient torsional strength
for most work overs and power swivel uses. The hydraulic drill-in adapter is the preferred assembly for new completions drilled with a rotary
table or when high torque and weight are required at the bit for fast drilling. The assembly includes a bit on bottom of the drill-in shoe. A tubing
stinger spaced with an expansion joint, and a drill-in adapter on the liner top. With liner on bottom , the setting tools are released, picked up,
and the liner is circulated clean. The tools and stinger are pulled out of the hole and a SCA is run in the hole, driven over the adapter and set.