Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
JOB NUMBER :
EQUIPMENT TAG :
PROJECT :
CLIENT :
DRAWING NO. :
设计:
校核:
审定:
日期:
版次:
Input Data
L1 L2
FV1 FV2
FH a FH
L3
CG
吊耳受力计算
DW TL
H
DH
WT
CALCULATION
Vessel weight W 1,500 lb
Impact factor IF 1.80 -
Yield strength of lug material YSL 16,600 psi
Yield strength of vessel material YSV 16,600 psi
Lug hole diameter DH 1.000 in
Tearout radius R 2.000 in
Width of lifting lug B 6.000 in
Thicknes of lift lug TL 0.375 in
Thickness of lug reinforcement washers TW 1.000 in
Distance from center of lug hole to bottom of the lug H 2.000 in
Fillet weld leg size - lug to shell weld LW 0.375 in
Required fillet weld leg size - washer to lug weld = 2 x TW / 3 LR 0.667 in
Actual filled weld leg size - washer to lug weld LP 0.000 in
Washer O.D. = 2 x (R - LP - 0.125) DW 3.750 in
H1
H2
R
H1
H2
NR
DH/2
DH TW TL TW
DW
LUG VERIFICATION
Minimum radius of the lug = 1.5 x DH Rmin 1.50 in
Actual lug radius R 2.00 in OK
H1 = R - DH / 2 H1 1.50 in
H2 = (DW - DH) / 2 H2 1.38 in
Actual lug section area = H1 x TL A1 0.56 in2
Actual washer section area = 2 x H2 x TW A2 2.75 in2
Total area = A1 + A2 A 3.31 in2
Radius to neutral axis
Term 1 = (2 x TW + TL) x ln[(H2 + DH/2) / (DH/2)] tr1 3.14 in
Term 2 = TL x ln[(H1 + DH/2) / (H2 + DH/2)] tr2 0.02 in
半径 = A / ( tr1 + tr2) NR 1.05 in
Excentricity = [A1x(H1+DH) + A2x(H2+DH)] / (2xA) - NR e 0.15 in
Bending moment = FV x NR / 2 MB 707 in-lb
Unit load = FV + MB x (R - NR) / (R x e) UL 3581 lb
Minimum required section area = UL / (0.66 x YSL) ALmin 0.33 in2
Minimum washer section area = Almin - A1 AWmin 0.00 in2
Minimum washer thickness = Awmin / (2 x H2) TW m 0.00 in
Actual washer thickness TW 1 OK
Designed by___________________
Verified by :___________________
___________________
Approved by
Date : ___________________