Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SOFTWARE
WHICH ACCESS COMMUNICATION PORTS MAY NOT RUN, BUT TRANSFERING DATA HAS A HIGH
SUCCESS RATE,
ALWAYS BACK-UP PRIOR TO INSTALLING USB/FIREWIRE SUPPORT.
FIREWIRE IEE1394:
IDE DigiDrive
(http://www.addonics.com/products/flash_memory_reader/ide_digidrive.asp)
USB1.x is the original standard which was supported from Windows95B onwards.
Then there was USB2.0, and it would appear that 2.0 devices are not always what
they seem! and
I quote "There was concern that people would NOT buy 1.1 peripherals to use with
their 2.0 machines, so
since 2.0 is a superset of 1.1, the names are now "2.0 High", "2.0 Full", and "2.0
Low" instead of "2.0",
"1.1 High", and "1.1 Low". This is an extract from
http://www.legge40.freeserve.co.uk/USB.htm which also
mentions FireWire. There are three standard complient controllers:
Novac UHCI/OHCI = INTEL, older VIA, NVIDIA, ALi and SiS chipsets chipsets
Panasonic UHCI/OHCI/EHCI = INTEL, VIA, NVIDIA, NEC, ALi and SiS chipsets
Matsushita UHCI/OHCI = not known
Medialogic UHCI/OHCI/EHCI = not known
DUSE UHCI/OHCI/EHCI = majority of onboard chipsets, please read the
manual, 4.4/4.9 are USB2.x complient
DRIVERS AVAILABLE
Except where marked $ are direct from manufacturers web sites
http://download.microsoft.com/download/dos622/Utility/2.23/DOS/EN-US/Mscdx223.exe
http://panasonic.co.jp/pcc/products/drive/cdrrw/kxlrw40an/download.html download
kxlr40an.exe
http://panasonic.co.jp/pcc/products/drive/cdrom/kxl840an/download.html download
kxl840an.exe
*Use WinRAR to extract following files from F2H folder in MS Windows 95/NT4
or later*
USBASPI.SYS version 2.06 {Panasonic} (device=usbaspi.sys /w/v)
USBCD.SYS version 1.00 {Panasonic} (device=usbcd.sys /d:usbcd001 & mscdex.exe
/d:usbcd001)
http://panasonic.co.jp/pcc/products/drive/other/driver/f2h_usb.exe
*Self-extracting archive under MS Windows 95/NT4 or later*
http://www.pocketec.net/downloads/duse_4_2.zip
or
$ http://www.datoptic.com/fwu2525.html download DOS_USB_4_2.zip
http://www.pocketec.net/downloads/duse_4_4.zip
http://www.pocketec.net/downloads/duse_4_9.zip
http://www.driver.novac.co.jp/driver/hd352u/hd352u_drv.html download
hd352u_dos.zip
http://www.driver.novac.co.jp/driver/sta_powerd/st751mu_drv.html download
ps_dos.zip
http://www.driver.novac.co.jp/driver/sta_black/bst_drv.html download bst_dos.zip
http://panasonic.co.jp/pcc/products/en/drive/cdrrw/kxlrw21a/download.html download
KXLRW21A.EXE
*Use WinRAR to extract following files from DOS folder in MS Windows 95/NT4
or later*
$ http://www-1.ibm.com/support/docview.wss?rs=0&q=usb+cd+drive&uid=psg1MIGR-
4TFT8J&loc=en_US&cs=utf-
download usb_cd.sys
*Please note that if sytem hangs insert the device= lines at beginning of
config.sys file, which is not accepted practice*
device=[{path}]USBASPI.SYS [/e] [/o] [/u] [/v] [/w] [/r] [/l[#]] [/f] [/slow]
[/nocbc] [/norst] [/noprt]
You can specify more than one controller type (e.g. /e /u). This switch can also be
used to force slower speed
operation on high-speed USB controllers & devices. The driver will scan for all
types of USB controllers, so use
these switches to specify which port types to enable. This allows for faster USB
scanning. By specifying /u or /o
and omitting /e, it forces Full-Speed mode on High-Speed devices.
In verbose mode. USBASPI displays details of controller type and USB devices it
detects. It displays the vendor and
product ID codes, the controller address range (memory map or I/O port map) of
controllers, and the connection
speed code for each device:
This switch is typically used on portable systems with an external USB floppy drive
connected to the single USB port
for boot-up. Used in conjunction with RAMFD.SYS so after the boot floppy is copied
to a RAM drive, (and after the
/W pause...) the USB floppy can be removed, and the target mass storage device can
be attached and detected:
/norst
/noprt
/f
USB REFERENCES
CATC USB4DOS
(http://www.sepoong.co.kr/equipment/communication/catc/usb/usb4dos.htm)
*http://www.informationweek.com/story/IWK20021003S0007*
*http://www.theinquirer.net/?article=10215*