Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
473
The pure product was heated on a water bath (III), (b), differs to a considerable degree from
under reduced pressure in order to remove the those of (a) and (d). The difference between
water molecules of crystallization. those two types of curves can be found, for
Dimethylglyoxime, DH2.-The compound was
instance, in the region from 3600 to 3300 cm-1
recrystallized from 94%-ethanol, and dried in a
or from 1800 to 1670 cm-1. Especially, the
vacuum desiccator over calcium chloride.
Measurements
band found at 1725 cm-1 on the curve of (a)
The infrared absorption spectra were obtained shows a very important meaning as discussed
with a Perkin-Elmer Model 21 Recording Spec- below.
trophotometer using sodium chloride prisms and
a Nujol suspension of the compound in question. Discussion
Recently Rundle and his co-workers6,7,8)
Results
have presented trustworthy data concerning
The results of the measurements are shown the crystal structure of bis-(dimethylglyoxi-
in Fig. 1 and Fig. 2. There is also inserted, mato)-nickel (II).
According to their X-ray analysis, the
complex molecule is planar and contains four
five-membered rings as shown in Fig. 3. Of
the direct evidence for the planar coordination stretching frequency for O-H-O hydrogen
of the two dimethylglyoximateions in the bonds. If it be applied their investigation
bis-(dimethylglyoximato)-cobalt(III)-derivative, to the present O-H stretching frequency,
since the existence of such a kind of hy- 1725 cm-1, the bond length of below 2.5k a
drogen bond as described above could not very short hydrogen bond, will be forecasted.
be expected with any other configuration As is seen in Fig. 1 and Fig. 2, some other
except the planar coordination. The appear- differences between the curves of bis- and
ance of the O-H stretching band on the curve, tris-(dimethylglyoximato)-complex can be also
(a), is, however, somewhat broad and shifted found. But the assignments of those bands
a little towards a longer wave-length com- are very difficult without more detailed
pared with the case of nickel (II)-complex, research. The author is, at present, investi-
(d). This may be perfectly understandable gating the fruits which are obtained by the
by taking into consideration the action of substitution of deuterium for hydrogen atom
an additional proton which is contained only concerned with the above O-H-O hydrogen
in the Feigl-Rubinstein's bis-(dimethylglyoxi- bonds).
mato)-cobalt(III)-complex, H*[Co(DH)2Cl2], and
not in the bis-(dimethylglyoximato)-nickel Summary
(II). It coincides also with Rundle's opining
that there are indications that very broad Infrared absorption spectra of bis- and tris-
bands, characteristic of strong hydrogen (dimethylglyoximato)-cobalt(III)-complex were
bonds, become sharper as the O-H-O bond measured. Some discussions concerning the
becomes symmetric. But the difference be- -H stretching band of the former complex O
tween the ionic radii of nickelous- and co- were given, and they reached the conclusion
baltic-ion may be also concerned with the that the band at 1725 cm-1. corresponds to
above facts. At any rate, it can be said the band at 1775cm-1 of the bis-(dimethyl-
that the O-H-O hydrogen bond in bis-(di- glyoximato)nickel (II) and is characteristic
methylglyoximato)-cobalt(III)-complexes has of the planar bis-(dimethylglyoximato)-com-
been proved to be the same kind of the plexes.
nature as established in the bis-(dimethyl-
The author wishes to thank Professor R.
glyoximato)-nickel(II).
Rundle and Parasols) have also discussed Tsuchida for his kind guidance and encou-
the relation between the bond length and the ragement throughout this work. Apprecia-
tion is also expressed to Mr. J. Fujita for his
* Although the hydrogen atom has been written con-
ventionally as the external cation of the comeplex anion, helpful discussions.
it is highly probable that the real structure of the com- This work was supported in part by a
plex should be considered to be " dichloro-dimethyl- grant from the Ministry of Education.
glyoximato-dimethylglyoxime-cobalt (III) " molecule,
[Co(DH2) (DH)Clp). If this proves to be the case, it
seems to be most probable that the proton attaches to an Department of Chemistry, Faculty of
oxygen atom.
9) To be submitted later.
Science, Osaka University, Osaka