ANGLES
Angles
Rolling tolerances - EN 10056-2
This European specifies tolerances on
shapes dimensions and mass of hot rolled
structural steel equal and unequal leg
angles.
Tolerances on shapes and dimensions
Leg length (a or b)
The deviation from nominal on length shall
be within the tolerance given in the folowing
table. For unequal leg angles, the longer leg
length (a) shall be used to determine the
tolerance band,
‘Section thickness (1)
‘The deviation from nominal on thickness
shall be within the tolerance given in the
following table.
Out of square (k)
‘Out-of-squareness of the section shall not
‘exceed the maximum following table. For
unequal leg angles, the longer lag length (a)
1993,
shall be used to determine the tolerance band.
+H
te an ncuang 100
restr han 100 opt and
eluing 180
‘rea hen 150 upto and
‘eting 200
10
15
ees nan 200
‘Straightness (4)
‘The deviation from straightness shall not exceed the
tolerances given in the following table, For unequal leg
angles, the longer leg length (a) shall be used to
datermine the tolerance band.
Ota | Tornce oer any
sergn_|_parar aogier
tea tecan einem | “imm| condos “ig”
Vpoamiinidra ts [eckt | 190 05
Uptoanchetidrgi00 |ozut | 20m 075
eter tan 200 a
Tolerance on mass.
‘The deviation from the nominal mass of any individual
piece shall not exceed:
‘a. 26% for thickness for ts 4mm or
b. 44% for thickness fort> 4mm
The deviation from the nominal mass is the difference
batween the actual mass of the piece and the
calculated mass. The calculated mass shall be
determined using a density of 7850 kg/m*.
Tolerance on length
‘The tolerance on ordered length shall be either:
‘a. 250mm; or
b. -0 1 +100mm where minimum lengths are
requested
ntinental 8
"s Tes
aNLES