Sei sulla pagina 1di 4

Belt Lacing Systems

Baler Belt Fastener Systems H20 & U20

MATO Australia Pty Ltd


PO Box 448
Kurri Kurri NSW 2327

Phone: 1300 850 795 Email: maus@mato.com.au


Fax: (02) 4936 1388 Web: www.mato.com.au
The MATO Hammer Systems H20 and U20 are designed for use on high
tensile round baler belts.
The system is particularly suitable for operation on small pulleys and offers
extremely long service life.

MATO Hammer System H20


The H20 series is a patented system manufactured from high
grade stainless steel. The low profile design of the fastener
and compression into the belt provides a very smooth surface
at the splice. The fastener operates well on small pulleys.
The design leaves minimum wear on the splice and pulley,
thereby offering extremely long service life.

A standard box of fasteners consists of 12 strips of fasteners


and 6 connecting pins to suit 175 mm (7’’) wide belt.

Longer fasteners and connecting pins are readily available.

MATO Hammer System H20 fasteners are installed using


either the 180mm or 350mm Eco Installation Unit.

Belt Strength in kN/m Up to 450


Belt Thickness in mm 5-6
Fastener Series H24BS
Connecting Pin T2F
Pin Diameter in mm 3.4

The Eco Installation Unit is available in two sizes with splice


widths up to 180mm and 350mm being installed in one step.

Installation can be performed either with a hammer and


punch, or with the Air Hammer.

Wider belts are spliced by a progressive step by step


installation.

This tool only requires a firm base for fastener installation and
is ideal for use in the field or workshop.
The H20 and U20 Systems offer:
• Smooth fastener profile
• High-grade stainless steel plates and rivets
• Easy installation and long service life

MATO Hammer System U20


The U20 series is a patented system manufactured from high
grade stainless steel. The low profile design of the fastener
and compression into the belt provides a very smooth surface
at the splice. The fastener operates well on small pulleys.
The design leaves minimum wear on the splice and pulley,
thereby offering extremely long service life.

A standard box of fasteners consists of 12 strips of fasteners


and 6 connecting pins to suit 175 mm (7’’) wide belt.

Longer fasteners and connecting pins are readily available.

MATO Hammer System U20 fasteners are installed using the


Profi range of Vice Lacers.

Belt Strength in kN/m Up to 450 Up to 450 Up to 450


Belt Thickness in mm 4-5 5-6 6-7
Fastener Series U24AS U24BS U24CS
Connecting Pin T1F T2F T2F
Pin Diameter in mm 3.0 3.4 3.4

The Profi 19 Vice Lacer is made from a high quality hardened


tool steel. A splice width up to 210mm (19 fasteners) can be
installed in one step.

Installation can be performed either with a hammer and


punch, or with the Air Hammer.

Wider belts are spliced by a progressive step by step


installation.

Smaller installation tools (Profi 5 and Profi 7) are also


available.
Accessories for Hammer Systems H20 & U20

Belt Skiver Belt Edge Chamfer Tool Air Hammer

Squaring Template Profi 19 Portable Tool Holder Portable Belt Cutter

Potrebbero piacerti anche