Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
en everything your dishwasher Read off the setting ... and then set
needs... Find out the water hard-
ness at your water utility – Hold down programme button B and switch on the main
Before using for the first A B C
switch, then release the buttons. The display of button B
Summary of instructions for dishwasher
company and enter
time, read the installation Reset and the number 4 set by the factory flash.
and operating instructions!
– Each time button B is depressed, the setting increases by
one; if 7 has been reached, the display jumps back to 0.
– Switch off the main switch. The selected setting has been
stored in the appliance.
Fill with rinse aid Everything is sparkling clean ... Refill whenever level indicator is light!
Spray arms ... Pull lower arm Unscrew upper Clean spray nozzles Insert lower arm ...
Remove upwards ... arm ... under flowing water
blockages/deposits (perhaps with
toothpick) ...
Residual water Waste water pump blocked Clean waste-water pump (see above). Utensils are not clean Utensils are situated close together Separate the utensils, prevent contact
in the appliance or one above the other points.
The programme has not yet ended Close appliance and switch on. Sand or gritty residue
or terminate programme (see on the utensils Too little detergent Follow manufacturer’s instructions
Terminating the programme). (detergent).
Unsuitable programme selected Select a more intensive programme.
Spray arm nozzles blocked Clean the spray arms (see above).
Appliance is not running / Supply fitting not open Open supply fitting.
stops Filters dirty, not seated firmly Clean the filters (see above).
Supply hose kinked Install supply hose without kinks.
Spray arms blocked Arrange the utensils so that the spray
Check water supply Supply fitting jammed or calcified 1. Unscrew water connection. arms can rotate freely.
Display lights up 2. Clean filter in the water connection.
3. Flow rate must be min. 9 l/min. when
water supply is open. Stains and streaks Rinse-aid dosage too high / too low Streaks: reduce dosage.
If the flow rate is less, replace the
supply fitting. Water or limescale stains: increase
dosage.
Milky film on the utensils Water softening system incorrectly set; Correctly set water softening system.
(removable)
No salt Refill with salt.
Plastic / utensils Too little detergent Follow manufacturer’s instructions
discoloured (detergent). Milky film, glasses Glasses not dishwasher-proof. Use dishwasher-proof glasses.
Discoloration caused by food colourings Discoloration is harmless; subsequent cloudy / dull
Use a detergent suitable for glasses.
(tomato sauce) rinse cycles will cause it to fade. (not removable)