Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Select [Password] Input password Input password again Press [OK] to save
Enroll Card
Enroll Enroll Card Enroll Card
Enroll Card
FP 1/2
press [OK] Password/ Card [OK] Swipe card! 008101-C
Esc-C Set-OK Cancel-C Sav-OK
2 Admin Setup: Admin(Administrator) has full access permissions to the device. It is recommended to assign a minimum of Place finger straight and
two administrators to each unit. flat on the sensor. Insure
MENU User Admin Setup Admin Setup Admin Setup Admin Setup maximum sensor coverage.
User Group Setup ID 008101
[OK] [OK] [OK] [OK] [OK]
Setup Admin Setup ID 000000 008101
USB Flash Admin Clear Esc-C Add-OK No-C Yes-OK Esc-C Add-OK
Place finger in the center of the sensor. Place finger on the sensor surface
Select [User] Selelct [Admin Setup] Input Admin ID Setup successful
V1.4
Package List Access Control Reader & Access Control Power Supply
+12
12I
09 09
10-29-09 THU 10-29-09 THU
or Access control
D/S GND
Exit Button
GND PUSH NO
FOR windows
EN C H ...
COMPACT
Windows 98
Windows 2000
CD-ROM
Windows XP
Windows Vista
Windows 7
C
ar
GND
Power on to unlock
NC
Installation Step
+
2 1
NC
Power off to unlock
1 Drill holes in the wall follow the hole position on back panel
2 Install and fix back panel, connect related cables
Access Control Reader & Switching Power Supply
3 Connect back panel to front panel by flat cable
3 4 Attach access control reader
+12V GND
Wiegand 0 Output
NC
7 DB2 Door Bell 2
8 DB1 Door Bell 1 Power off to unlock
2
3 D/S Door Switch Connect the front part of device
GND D/M
5 GND GND
12I
COM NO
6 NO NO
D/S GND
+12V GND
I II III ON OFF
RELAY DELAY PROGRAM
PROGRAM MODE - (YELLOW)
COM
12V-I
7
POWER
SUPPLY LOCK
12V-O
COM NORMAL MODE - (BLUE)
ANVIZ DEVICE
GND GND
NC
8 NC NC GND D0
RELAY OUT
NO GND
BUTTON
EXIT
COM BUT
NC
Exit Button
Important notice: Please follow the wiring diagram as it is displayed. Damaged products due to Power on to unlock