Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Carbon laminates (Fiber Reinforced Polymer) for the external strengthening of concrete, metal
and wood members
MBrace FRP LAMINATE can be used in a wide Density g/cm 1.54 1.61 1.61
range of application areas, ranging from small local
repair of private buildings (e.g. balconies) to large Inter Laminar 70 MPa 70 MPa 70 MPa
industrial applications (e.g. strengthening of cooling Shear Strength
Thermal -6 -6
towers). 0.6 x 10 0.6 x 10 0.6 x 10-6
Expansion
FEATURES AND BENEFITS
Note
Excellent weight to strength ratio due to the superior
Values above are typical mean values obtained from
material characteristics compared to traditional
regular testing. Some variation may occur dependant
bonding techniques.
on batch, size, and test method sensitivity. Allowance
Lightweight material and therefore minimal additional
should be made for this in the design process. The
deadweight to structures.
designer is advised to satisfy himself, by prior testing if
Easy and fast to apply. MBrace FRP LAMINATEs
necessary, that the grade chosen will conform to the
are easy to handle, can be cut on site and offer a
performance criteria for his specific design.
special peel ply to keep the adhesion surface clean.
Excellent adhesion to substrates due to optimized
Application Procedure / Preparation of Substrate
laminate surface texture.
Surfaces that are in good condition or that are restored
Enables the amount of reinforcement to be calculated
with putty from the MBrace FRP range should be
in relation to the performance required or the stress
sanded down. For degraded structures, the whole
flow.
damaged area should be removed by scarifying, hydro-
Fast maintenance and application, reducing costs.
demolition or a comparable technique and then
Non corrosive, therefore high durability and low
structural restoration carried out with mortar of the
maintenance.
EMACO range.
Suitable for post tensioning applications.
Remove oils, grease, dust or any other loose material
from the surface.
Cut MBrace FRP LAMINATE according to the
required length using suitable cutting devices.
Remove protective peel ply film from the surface of Installation should only be carried out by trained and
MBrace FRP LAMINATE to be adhered. experienced specialist contractors. Site quality control
should be the responsibility of an independent
Apply one layer of MBrace LAMINATE ADHESIVE organization appointed by the client or his
1 1.5 mm thick on both the surfaces (concrete and representatives.
LAMINATE).
Surfaces exposed to U.V. rays should be protected
Apply MBrace LAMINATE and using the correct roller, within two days (maximum seven days) with a selected
exert a constant pressure by moving the tool both ways product from the MASTERSEAL line in order to ensure
in the direction of the fibers. perfect bonding between the protective layer and FRP.
50 x 1.2 8.5 15
50 x 1.4 9 16
80 x 1.2 12 22
80 x 1.4 13 24
100 x 1.2 15 27
100 x 1.4 16 29
The technical information and application advice given in this BASF Construction Chemicals publication are
STATEMENT OF based on the present state of our best scientific and practical knowledge. As the information herein is of a
general nature, no assumption can be made as to a product's suitability for a particular use or application and
RESPONSIBILITY no warranty as to its accuracy, reliability or completeness either expressed or implied is given other than
those required by law. The user is responsible for checking the suitability of products for their intended use.
NOTE Field service where provided does not constitute supervisory responsibility. Suggestions made by BASF
Construction Chemicals either orally or in writing may be followed, modified or rejected by the owner,
engineer or contractor since they, and not BASF Construction Chemicals, are responsible for carrying out
procedures appropriate to a specific application.