Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
A-A-59125/18
03 June 2011
SUPERSEDING
MIL-T-55164/18
30 June 1967
The requirements for acquiring the product described herein shall consist of this sheet and CID A-A-59125.
REQUIREMENTS:
Dimensions and configuration: See figure 1.
FSC 5940
NOTES:
1. Dimensions are in inches.
2. Metric equivalents (to the nearest 0.01 millimeter) are given for general information only and are based upon
1 inch = 25.4 millimeters.
3. Unless otherwise specified herein, tolerance is 0.xxx0.016.
FIGURE 1. Terminal board Continued.
2
Source: http://www.assistdocs.com -- Downloaded: 2014-01-29T15:48Z
Check the source to verify that this is the current version before use.
A-A-59125/18
TABLE I. Dimensions.
Maximum
Terminal
Type Recommended wire number of Federal
Dimensions nuts
designation terminal lugs terminal lugs stock class
required
for each stud
A0.016 B0.016 MIL-T-16366 SAE-AS17143
inch (mm) inch (mm) (dash no.)
-1
13TB4 1.625 (41.28) 1.875 (47.63) L-80
{ -2
-3 } 3 4 FSC-5940
Review Activities:
Navy AS
DLA GS
NOTE: The activities listed above were interested in this document as of the date of this document. Since
organizations and responsibilities can change, you should verify the currency of the information above using the
ASSIST Online database at https://assist.daps.dla.mil.
3
Source: http://www.assistdocs.com -- Downloaded: 2014-01-29T15:48Z
Check the source to verify that this is the current version before use.