Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
5 4 EN 1 6 BP NC 8 NC
VIN 2 7 EN
GND 2 5 NC
7 NC 3 6 BP
2 3 VIN 3 4 VOUT VOUT 4 5 GND
VIN GND EN
WDFN-6L 2x2 MSOP-8
SC-70-5/SOT-23-5/TSOT-23-5
EN Shutdown VIN
Quick and
Start Logic Control
BP VREF
+ MOSFET
Driver
-
Error
Amplifier VOUT
Current-Limit
and
Thermal
Protection
GND
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
Electrical Characteristics
(VIN = VOUT + 1V, CIN = COUT = 1F, CBP = 22nF, TA = 25 C, unless otherwise specified)
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
Note 1. Stresses beyond those listed Absolute Maximum Ratings may cause permanent damage to the device. These are
stress ratings only, and functional operation of the device at these or any other conditions beyond those indicated in
the operational sections of the specifications is not implied. Exposure to absolute maximum rating conditions may
affect device reliability.
Note 2. JA is measured at TA = 25C on a low effective thermal conductivity single-layer test board per JEDEC 51-3.
Note 3. Devices are ESD sensitive. Handling precaution is recommended.
Note 4. The device is not guaranteed to function outside its operating conditions.
Note 5. The dropout voltage is defined as VIN VOUT, which is measured when VOUT is VOUT(NORMAL) 100mV.
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
85
1.6
80
1.5
75
1.4
70
1.3 65
1.2 60
-50 -25 0 25 50 75 100 125 -50 -25 0 25 50 75 100 125
Temperature (C) Temperature (C)
200
PSRR (dB)
-20
TJ = 25C
150
-40
TJ = -40C
100
ILoad = 100mA
-60
50 ILoad = 10mA
0 -80
10
0.01 100
0.1 1K
1 10K
10 100K
100 1M
1000
0 0.05 0.1 0.15 0.2 0.25 0.3
Load Current (A) Frequency (kHz)
(Hz)
1.25 0
Output Voltage
1.00
2
(V)
1
0.75
0
0.50
-50 -25 0 25 50 75 100 125 Time (500s/Div)
Temperature (C)
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
Load Current
Load Current
(mA)
(mA)
50 200
0 0
Deviation (mV)
Output Voltage
Deviation (mV)
Output Voltage
20 50
0 0
-20 -50
5 5
4 4
Deviation (mV)
Deviation (mV)
Output Voltage
Output Voltage
10 10
0 0
-10 -10
Noise Noise
VIN = 4.5V RT9193-30xB VIN = 4.5V RT9193-15xU5
CIN = COUT = 1F, X7R ILOAD = 50mA CIN = COUT = 1F, X7R ILOAD = 50mA
200 200
100 100
Noise (V)
Noise (V)
0 0
-100 -100
-200 -200
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
Start Up
VIN = 5V RT9193-28xU5
EN Pin Voltage
0
Output Voltage
2
(V)
Time (10s/Div)
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
1
The maximum power dissipation depends on the thermal
Stable
0.1
resistance of IC package, PCB layout, the rate of
surroundings airflow and temperature difference between
0.01
junction to ambient. The maximum power dissipation can
RT9193-15xU5 be calculated by following formula :
CIN = COUT = 1F, X7R
0.001 PD(MAX) = ( TJ(MAX) TA ) /JA
0 50 100 150 200 250 300
Where T J(MAX) is the maximum operation junction
Load Current (mA)
temperature 125C, TA is the ambient temperature and
Figure 1
the JA is the junction to ambient thermal resistance.
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
500
TSOT-23-5/
SOT-23-5
400
SC 70-5
300
200
100
0
0 25 50 75 100 125
Ambient Temperature (C)
Figure 2. Derating Curve for Packages
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
H
D
L
C B
A
A1
e
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
H
D
L
C B
A
A1
e
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
H
D
L
C B
A
A1
e
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
D D2
E E2
SEE DETAIL A
1
e
b 2 1 2 1
A
A3
A1
DETAIL A
Pin #1 ID and Tie Bar Mark Options
Copyright 2013 Richtek Technology Corporation. All rights reserved. is a registered trademark of Richtek Technology Corporation.
D
L
E E1
A A2
A1
b
Richtek products are sold by description only. Richtek reserves the right to change the circuitry and/or specifications without notice at any time. Customers should
obtain the latest relevant information and data sheets before placing orders and should verify that such information is current and complete. Richtek cannot
assume responsibility for use of any circuitry other than circuitry entirely embodied in a Richtek product. Information furnished by Richtek is believed to be
accurate and reliable. However, no responsibility is assumed by Richtek or its subsidiaries for its use; nor for any infringements of patents or other rights of third
parties which may result from its use. No license is granted by implication or otherwise under any patent or patent rights of Richtek or its subsidiaries.
www.richtek.com DS9193-16 January 2013
14