Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
com
1-Guide (Position)
See AWS D1.1, Table 4.7: PQR Essential Variables for ESW
and EGW process
PAGE 1 OF 8 WPSAmerica.com
WPSAmerica.com
T from 1/8 in. (3 mm), but less than 1 in. (25 mm):
Qualified Thickness Range: 1/8 in. (3 mm) Min., 2T Max.
PAGE 2 OF 8 WPSAmerica.com
WPSAmerica.com
AWS D1.1 (Structural Welding Code-Steel)
Qualified Fillet Size: Max. tested single pass and smaller; Min.
tested multiple pass and larger
(See AWS D1.1, Table 4.4 [Plate]/ Table 9.12 [Pipe])
T over 3/8 in. (10 mm), but less than 3/4 in. (20 mm):
Qualified Thickness Range: 0.5T Min., 2T Max.
PAGE 3 OF 8 WPSAmerica.com
WPSAmerica.com
AWS D1.1 (Structural Welding Code-Steel)
PAGE 4 OF 8 WPSAmerica.com
WPSAmerica.com
AWS D1.1 (Structural Welding Code-Steel)
4-Guide (Base Metal Selection)
AWS D1.1 Table 4.8:
Table 3.1, Table 4.9 and Unlisted Steels Qualified by PQR
6-Guide (Joint)
AWS D1.1, Table 4.5: Essential Variables for Joints:
-A change in groove type (e.g., single-V to double-V), except
qualification of any CJP groove weld qualifies for any groove
detail conforming to the requirements of 3.12 (PJP-Figures 3.2)
or 3.13 (CJP-Figures 3.3), 9.10, or 9.11 [Pipe].
PAGE 6 OF 8 WPSAmerica.com
WPSAmerica.com
AWS D1.1 (Structural Welding Code-Steel)
See AWS D1.1, Table 4.7: PQR Essential Variables for ESW
and EGW process
PAGE 7 OF 8 WPSAmerica.com
WPSAmerica.com
PAGE 8 OF 8 WPSAmerica.com