Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Modos de configuracin
Negociacin
o PAgP Port Aggregation Protocol
o LACP Link Aggregation Control Protocol
Manual
o Mode ON
Configuracin de Etherchannel
En el ejemplo, vamos a ver cmo configurar Etherchannel
en modo manual con mode on. Tenemos dos switches
(CHIP y CHOP) conectados entre s en cuatro de sus
puertos (fa0/1, fa0/2, fa0/3 y fa0/4). Lo primero que
vamos hacer es ingresar en el modo de configuracin de
interfaz, e indicar el grupo y el modo de configuracin del
etherchannel.
Me parecio extrao encontrar poca informacin escrita en espaol acerca de como hacer un
etherchannel utilizando Packet Tracer, asi que aca voy a escribir los comandos para que queden
para la posteridad y screenshots para ir viendo como deberia de quedarnos nuestro
etherchannel.
Switch>enable
Switch#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Switch(config)#spanning-tree mode rapid-pvst
Switch(config)#spanning-tree portfast default
Switch(config)#exit
Luego juntamos esto con 2 routers, uno de cada lado o uno a cada switch por asi decirlo; ya que
esta nueva configuracion de los switches se conoce como multi-layer-switch.
Switch#show spanning-tree
VLAN0001
Spanning tree enabled protocol rstp
Root ID Priority 32769
Address 0001.4391.C03E
This bridge is the root
Hello Time 2 sec Max Age 20 sec Forward Delay 15 sec
Switch#
Configuramos ambos switches de la misma manera, creando el canal en el rango de los puertos
donde hicimos el etherchannel fsicamente.
Switch>enable
Switch#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Switch(config)#int port
Switch(config)#int port-channel 1
Switch(config-if)#switchport mode trunk
Switch(config-if)#exit
Switch(config)#int ran f0/1-2
Switch(config-if-range)#channel-group 1 mode auto
Switch#show etherchannel
Channel-group listing:
----------------------
Group: 1
----------
Group state = L2
Ports: 2 Maxports = 8
Port-channels: 1 Max Portchannels = 1
Protocol: PAGP
Switch#
Ahora que tenemos nuestro etherchannel arriba, vamos a configurar los routers con sus
respectivas direcciones IP.
Router>enable
Router#conf t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#int f0/0
Router(config-if)#no shut
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/0, changed state to
up
Router(config-if)#ip add 10.10.0.1 255.255.255.0
Router(config-if)#exit
Teniendo cuidado de cambiar la IP en el segundo router.
Terminamos haciendo un ping entre routers para verificar la velocidad de conexion entre ellos.
Router#ping 10.10.0.2
Router#
Y asi se miraria nuestra configuracion del etherchannel en Packet tracer:
Resultado final
Eso si, para que esto sea funcional debemos de tener tarjetas de red que soporten esta capacidad
de envio/recepcion.