Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Single-V and single-U butt welds are used for sheets of thickness
a. upto 10mm
b. 5-15mm
c. 10-20mm
d. 15-25mm
(Ans:b)
Double-V and double-U butt welds are used for plates of thickness
a. 1-5mm
b. 5-10mm
c. 10-15mm
d. Over 15mm
(Ans:d)
The resistance welding process suitable for welding ferrous and non-
ferrous metals upto 8mm thickness is
a. Spot welding
b. Projection welding
c. Butt welding
d. Pressure welding
(Ans:a)
In spot welding, for lap joint, the diameter of welded zone (weld
nugget) should be
a. 4t+2.5mm
b. 8t+2.5mm
c. 12t+2.5mm
d. 2t+2.5mm
Where t is thickness of sheet
(Ans:d)
Which flame is suitable for welding of non ferrous metals (brasses and
bronzes)?
a. Oxidising flame
b. Carburising flame
c. Neutral flame
d. None of the above
(Ans:a)
Which of the
a. Heat following
effected zone is not
and true for are
distortion gas less
welding?
as compare to arc
welding
b. It is suitable for thin sheets
c. It is slower than arc welding
d. There are safety problems in storing and handling the gases
(Ans:a)