Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Installation Instructions
Model DB-HR
Detector Base
DB-HR RELAY BASE
LINE 1 LINE 1 TO NEXT DEVICE
DO NOT USE AN END
REMOTE RELAY BASE
OF LINE DEVICE
MODEL DB-HR
TO INITIATING CIRCUIT
OF SIEMENS BUILDING
TECHNOLOGIES, INC. 5 RELAY* *THE RELAY CONTACTS ARE
NO
CONTROL PANEL C
CONTACTS SHOWN IN THE NON-ALARM/
6 NC 3A, 120 VAC SYSTEM RESET CONDITION.
3A, 30 VDC
TO NEXT DEVICE
LINE 2 LINE 2 DO NOT USE AN END
OF LINE DEVICE
LINE 1 AND LINE 2 CAN BE EITHER LINE OF THE LOOP.
Figure 1
Wiring Diagram For DB-HR Using HFP-11 And HFPT-11 Detectors
Detector and base locations shall follow the drawings provided or approved
by Siemens Building Technologies, Inc. or its authorized distributors. This is
extremely important! The detector placements shown on these drawings
were chosen after a careful evaluation of all facets of the protected area.
When drawings are not available, refer to Detector Placement section of
detector Installation/Wiring Instructions and to NFPA 72, National Fire Alarm
Code and CAN/ULC-S524.
BASE WIRING
Refer to Figure 2.
ALARM LED
LOCATION WITH NT
DETECTOR T PAI
NO
INSTALLED DO
IN BASE
6
1b
5
1a
BASE
MOUNTING MOUNTING
HOLE COVERS HOLES
Figure 2
Mounting the Base
P/N 315-033220-2