Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This screen allows you to manage specific functions for access and security.
Router Mode
If "Router Mode" option is selected, the device will reboot automatically
and operate in Router Mode. The routing functionality will be enabled.
Wifi and LAN will also active. The management IP address will change
to 192.168.0.1.
Connection Mode
If your service provider supports DHCP or you are connecting through a
dynamic IP address, select DHCP (this option usually applies to cable
connections).
If you are connecting through a static IP address, select Static IP. Then
configure the following:
Internet IP Address
Enter the Gateway's IP address, as seen from the Internet.
Subnet Mask
Enter the Gateway's Subnet Mask, as seen from the Internet
(including your service provider).
Default Gateway
Enter the IP address of the service provider's server.
MTU Size
MTU is the Maximum Transmission Unit. It specifics the largest packet
size permitted for Internet transmission. The recommended size, entered
in the MTU Size field, is 1500. To have the device select the best MTU
for your Internet connection, keep the default setting, 0.
Gateway Change Current User Name to, Change Password to, and Re-Enter
Access New Password
You can change the Gateway User Name and Gateway Password. Enter
a new User Name and Password. Enter the Password again in the Re-
Enter New Password field to confirm.
Enter the port number that will be open to outside access. The default
setting is 8080. This port must be used when you establish a remote
connection.
UPnP
If you want to use UPnP, keep the default setting, Enable. Otherwise,
select Disable.
Click the Save Settings button to apply your changes or the Cancel Changes button to
cancel.